2011 Saab 9-3

The defect

General Motors LLC (GM) is recalling certain model year 2006-2011 Saab 9-3 vehicles manufactured May 31, 2002, to February 15, 2011, 2006-2009 Saab 9-5 vehicles manufactured June 7, 2005, to May 28, 2009, and 2008-2009 Saturn Astra vehicles manufactured April 11, 2007, to July 24, 2008. Upon deployment of the driver's frontal air bag, excessive internal pressure may cause the inflator to rupture.

The risk

In the event of a crash necessitating deployment of the driver's frontal air bag, the inflator could rupture with metal fragments striking the driver or other occupants resulting in serious injury or death.

The remedy

GM will notify owners, and dealers will replace the driver's frontal air bag inflator on Saab 9-3 and 9-5 vehicles and will replace the driver's frontal airbag module on Saturn Astra vehicles, free of charge. The recall began on March 1, 2017. Owners may contact Saab customer service at 1-800-955-9007 or Saturn customer service at 1-800-553-6000. GM's number for this recall is 28810.

General Motors LLC · up to 113,716 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain model year 2004-2011 Saab 9-3 Convertible vehicles manufactured July 30, 2003, to February 15, 2011. In the affected vehicles, the driver's side front seat belt retractor may break, causing the seat belt webbing not to retract.

The risk

In the event of a crash, a seat belt that has not retracted may not properly restrain the seat occupant, increasing their risk of injury.

The remedy

GM will notify owners, and dealers will replace the driver's seat belt retractor, free of charge. The recall began on October 6, 2015. Owners may contact Saab customer service at 1-800-955-9007. GM's number for this recall is 14222. Note: Special Coverage 10086 will replace the passenger side seat belt retractor if it fails, free of charge, for the life of the vehicle.

General Motors LLC · up to 28,789 vehicles across all model years covered

The defect

SAAB IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 PASSENGER VEHICLES MANUFACTURED FROM JUNE 2010 THROUGH DECEMBER 2010. CERTAIN FUEL PUMPS INSTALLED AS ORIGINAL EQUIPMENT MAY HAVE INTERNAL COMPONENTS WITH INCORRECT SPECIFICATIONS.

The risk

THE SUBJECT FUEL PUMPS CAN SEIZE CAUSING THE ENGINE TO STALL WHICH INCREASES THE RISK OF A CRASH.

The remedy

SAAB WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMPS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2011. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.

SAAB CARS NORTH AMERICA, INC. · up to 4,400 vehicles across all model years covered

Still open engineering analysis · opened September 17, 2021

the air bags

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

crash · towed · 90,000 miles

DRIVERS SIDE AIRBAG SPONTANEOUSLY DEPLOYED WHILE IN MOTION ON A CITY STREET GOING IN A FORWARD, STRAIGHT MOTION.

NHTSA complaint 11352234. Filed by an owner and not verified by NHTSA or by us.

driver side seat belt not retracting, there is a recall but does not include this vin number.

NHTSA complaint 11419150. Filed by an owner and not verified by NHTSA or by us.

103,000 miles

TL* THE CONTACT OWNS A 2011 SAAB 9-3. THE CONTACT STATED THAT WHILE DRIVING, THE AIR BAG SENSOR WARNING LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER AND LOCAL DEALER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

NHTSA complaint 11326728. Filed by an owner and not verified by NHTSA or by us.

120,000 miles

TL* THE CONTACT OWNS A 2011 SAAB 9-3. THE CONTACT DETECTED A STRONG ODOR OF COOLANT INSIDE THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE VEHICLE WAS LEAKING COOLANT AND SCREWS WERE MISSING THAT CONNECTED THE TRANSMISSION TO THE MOTOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE WARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

NHTSA complaint 11151821. Filed by an owner and not verified by NHTSA or by us.

PUMP ON REAR XWD FAILURE

NHTSA complaint 11074242. Filed by an owner and not verified by NHTSA or by us.

LETTER IS RESPONSE TO THE RECALL OF A DEFECTIVE AIR BAG; SEEKING HELP FOR THIS DILEMNA NHTSA CAMPAIGN ID NUMBER 16V063. *LD THE CONSUMER STATED THE RECALL EXCEEDED A REASONABLE AMOUNT OF TIME. UPDATED 06/29/2017 *JS

NHTSA complaint 11002290. Filed by an owner and not verified by NHTSA or by us.