2012 Acura TSX Sport Wagon

The defect

Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2014 TSX Sport Wagon, 2010-2013 ZDX, 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic and Civic Hybrid, 2008-2010 Civic GX NGV, 2012-2015 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2014 Fit EV, 2010-2014 Insight, and 2009-2015 Pilot vehicles. The vehicles are equipped with passenger frontal air bag inflators assembled as a recall remedy part or replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

The risk

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

The remedy

Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began August 12, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are F5F and Q5E.

Honda (American Honda Motor Co.) · up to 9,555 vehicles across all model years covered

The defect

Honda (American Honda Motor Co.) is recalling certain 2009-2014 Acura TSX, 2011-2013 TSX Sport Wagon, and 2010-2012 ZDX and 2008-2012 Honda Accord, 2010-2011 Accord Crosstour, 2006-2011 Civic, Civic Hybrid and Civic NGV, 2012-2014 Crosstour, 2007-2011 CR-V, 2009-2013 Fit, 2010-2013 Insight, and 2009-2015 Pilot vehicles. The front passenger air bag inflator may have been installed incorrectly during replacement.

The risk

An incorrectly installed air bag inflator may not properly deploy the passenger frontal air bag in the event of a crash, increasing the risk of injury.

The remedy

Honda will notify owners, and dealers will inspect the inflator installation and, if necessary, replace the passenger frontal air bag module assembly, free of charge. The recall began July 5, 2019. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are M4O, P4R, T4Q, and W4P.

Honda (American Honda Motor Co.) · up to 19,138 vehicles across all model years covered

The defect

Honda (American Honda Motor Co.) is recalling certain 2010-2013 Acura TSX, ZDX, Honda Accord Crosstour, Fit, Insight and Pilot vehicles, 2011-13 Acura TSX Sportswagon, 2010-2012 Honda Accord,, 2010-2011 Honda Civic, Civic NGV, Civic Hybrid and CR-V vehicles and 2013 Honda FCX Clarity and Fit EV vehicles ever registered in the states of Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands or "Zone A." Additionally, Honda is recalling certain 2010-2012 Acura TSX, Honda Accord, Accord Crosstour, Fit and Pilot, 2010-2011 Honda Civic, Civic NGV, Civic Hybrid and CR-V, and 2010 Acura ZDX and Honda Insight vehicles ever registered in the states of Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia or "Zone B." Unless included in Zones A or B above, Honda is recalling certain 2009 Acura TSX, Honda Accord, Civic, Civic NGV, Civic Hybrid, CR-V, Fit, and Pilot vehicles ever registered in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the frontal air bag modules, and used as original equipment or replacement equipment (such as after a vehicle crash necessitating replacement of the original air bags), may explode due to propellant degradation occurring after long-term exposure to higher absolute humidity, temperature and temperature cycling.

The risk

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

The remedy

Honda will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. The recall began February 16, 2018. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are B0K and L0J.

Honda (American Honda Motor Co.) · up to 691,726 vehicles across all model years covered

The defect

Honda (American Honda Motor Co.) is recalling certain 2009-2012 Acura TSX, 2011-2012 Acura TSX Wagon, 2010-2012 Acura ZDX, 2008-2012 Honda Accord, 2010-2012 Honda Accord Crosstour and Honda Insight, 2009-2012 Honda Fit, 2009-2012 Pilot, 2007-2011 Honda CR-V, 2012 Honda FCX Clarity and 2006-2011 Honda Civic, Civic Hybrid, Civic NGV vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, if not included in "Zone A" above, Honda is recalling certain 2009 Acura TSX, Honda Fit and Pilot, 2008-2009 Honda Accord, 2006-2009 Civic, Civic Hybrid and Civic NGV, and 2007-2009 Honda CR-V vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, if not included in "Zone B" above, Honda is recalling certain 2008 Honda Accord, 2006-2008 Honda Civic, Civic Hybrid and Civic NGV and 2007-2008 Honda CR-V vehicles originally sold, or ever registered, in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin, and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

The risk

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

The remedy

Honda will notify owners, and dealers will replace the front passenger side air bag inflator, free of charge. The manufacturer has mailed an interim notification, and will send a second notification when parts are available. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for this recall are KE1 and KE2.

Honda (American Honda Motor Co.) · up to 977,708 vehicles across all model years covered

Closed engineering analysis · opened April 19, 2019 · closed September 19, 2024 · led to recall 20V024

the air bags

The Office of Defects Investigation (ODI) opened this investigation to determine if the failure of airbags to deploy during severe crashes, in certain vehicles, was the result of a safety related defect.  During the investigation a complex failure was studied that can result in non-deployment of subject vehicle air bags and other restraint system devices in severe crash events. The subject vehicles may be equipped with an airbag control unit (ACU) for the supplemental restraint system (SRS) Electronic Control Unit (ECU) manufactured by ZF-TRW.  The ECU receives signals from crash sensors mounted in the vehicle and deploys the vehicle air bags and seat belt pretensioners in accordance with manufacturer design specifications.  The ECU in the subject vehicles contains a model DS84 application-specific integrated circuit (ASIC) which controls the communication of the crash sensor signal, firing commands (i.e., when to deploy the airbag(s) and/or pretensioners), and fault information (e.g., diagnostic trouble codes). In September 2016, FCA announced recall 16V-668 for certain model year (MY) 2010 to 2014 Chrysler, Dodge and Jeep products manufactured with the subject ZF-TRW ACU.  In this recall, FCA discussed an EOS condition that resulted in a failure of the subject DS84 ASIC, which caused air bag non-deployment.  FCA noted that the defect condition had only been observed in vehicles equipped with sensor harnessing routed across the front of the vehicle.  Other FCA vehicles that also used the subject ACU, but were not equipped with cross-car harnessing, had not experienced EOS failures, despite similar time in service. During the course of this investigation, ODI sent two separate Information Request (IR) letters to six vehicle manufactures (including FCA, Hyundai, Honda, Kia, Mitsubishi, and Toyota) and one IR letter to ZF-TRW.  These IR letters resulted in ODI receiving comprehensive data from these manufacturers and suppliers. Studies of this data found that the DS84 ASIC does not have sufficient protection against negative electrical transients or electrical overstress (“EOS”) that can be generated in certain severe crashes.  An electrical transient occurs when the electrical power supplied to a circuit changes momentarily over a short duration of time.   In these severe crash cases, the crash sensors and other powered wiring can be damaged and short circuited so as to create a negative electrical transient of sufficient intensity and duration (that are outside the vehicle manufacturer's specification) to damage the ASIC before the restraint device deployment signal is received by the SRS ECU.  This damaged signal can lead to incomplete or nondeployment of the air bags and/or pretensioners.  Airbag non-deployment and/or lack of pretensioner operation can increase the risk or severity of injury in a crash.A total of 8 fatalities and 14 injuries were associated with known EOS events. The common element in all investigated manufacturers vehicles is the SRS ECU containing a DS84 ASIC manufactured by ZF-TRW.  The risk associated with the ASIC is equally shared among all OEMS involved in the investigation.  The actual real-world risk can be mitigated by other factors which were assessed by ODI during this investigation. The first mitigating factor involves protections built into the ACU design which protect the DS84 ASIC from damage.  There are multiple strategies and levels of protection employed by different OEMs that provide effective EOS mitigation.  The two most common strategies at the ACU level are circuit protection diodes on the remote senor signal lines, and current limiting resistors that protect critical components. The second mitigating factor is found at the vehicle level and involves the location and routing of the wires leading from the crash sensors to the SRS ECU.  If the wires are well protected in a crash and are not routed with other power wires carrying large currents, the risk for an EOS event is significantly reduced or eliminated. These design specific factors combine to produce a spectrum of risk for the vehicles equipped with ACUs using the DS84 ASIC.  Given the many of years of field exposure, it is possible to divide the subject population into two groups; vehicles which have experienced EOS events, and vehicles which have not experienced EOS field events. Four of the six OEMs involved in this investigation have experienced EOS field events on at least one of their models equipped with a DS84 ASIC.  All vehicle models (including the Toyota models identified in the Failure Report Summary of the opening resume for this investigation) with field events have been recalled.  In an abundance of caution, ODI kept this investigation open five years to monitor field performance and did not identify any field events on vehicles not included in existing safety recalls. Given the spectrum of risk identified in this investigation and that all vehicles with a demonstrated unreasonable risk have been recalled, ODI is closing this investigation. ODI is closing this investigation with the following manufacturer safety recalls: 16V-668, 18E-043, 18V-137, 18V-363, and 20V-024.  With the recall actions taken by the subject vehicle and equipment manufacturers, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exists on other model or model year vehicles outside of the recall scopes. The agency reserves the right to take further action if warranted by the circumstances.

95,000 miles

POWER STEERING MODULE DIED AT 95K... FIRST NOTICED AFTER STARTING IT UP AT THE END OF WORK DAY IN THE PARKING GARAGE. IT WAS DRIVEABLE WITH LOTS OF EXTRA MUSCLE DURING ANY KIND OF TURN. AFTER DIAGNOSTIC PERFORMED BY DEALER, ISSUE DID NOT OCCUR FOR A 30 MINUTE DRIVE HOME. THE NEXT MORNING THOUGH...IT WAS OUT AGAIN.

NHTSA complaint 11209063. Filed by an owner and not verified by NHTSA or by us.

103,000 miles

EPS (ELECTRIC POWER STEERING UNIT) FAILED WHILE DRIVING ON HIGHWAY. AMBIENT TEMP OUTSIDE WAS -11 F. LIGHT TURNED OFF OVERNIGHT. NEXT DAY WAS FINE, -4 F, NO WARNING LIGHT, POWER STEERING ACTIVE. DAY AFTER, AT MORNING STARTUP, 20 F, LIGHT WAS BACK ON. NO POWER STEERING SINCE.

NHTSA complaint 11174451. Filed by an owner and not verified by NHTSA or by us.

117,000 miles

I WAS DRIVING AROUND 30 MPH AND THE EPS WARNING LIGHT CAME ON, THEN IMMEDIATELY AFTER THE POWER STEERING WENT OUT. I ALMOST CRASHED AS THE WHEEL WAS EXTREMELY DIFFICULT TO TURN.

NHTSA complaint 11165408. Filed by an owner and not verified by NHTSA or by us.

57,000 miles

VEHICLE HAS LESS THAN 57K MILES AND FANTASTICALLY MAINTAINED. WHILE DRIVING WITH MY 3.5 YEAR OLD DAUGHTER THIS AFTERNOON, THE POWER STEERING LIGHTS AND MESSAGE CAME UP AND THE STEERING IMMEDIATELY FAILED CAUSING PANIC FOR MY DAUGHTER'S AND MY SAFETY. THE INFOTAINMENT SYSTEM ADVISED OF THE PROBLEM AND SUGGESTED TO TURN VEHICLE OFF THEN BACK ON AND THE PROBLEM PERSISTED FOR THE NEXT 4 MINUTES OF DRIVING THEN A MANDATORY STOP WAS MADE, VEHICLE TURNED OFF AND SAT FOR 20 MINUTES THEN STARTED AGAIN AND PROBLEM WAS NONEXISTENT BUT WHILE DRIVING FOR ANOTHER 4 MINUTES, THE SYSTEM SHUT OFF AGAIN WITHOUT WARNING. LUCKILY I WAS NEAR MY HOME ABLE TO PARK. THIS WAS AN AWFUL FEELING AND I FEARS FOR MY …

NHTSA complaint 11128834, quoted in part. Filed by an owner and not verified by NHTSA or by us.

61,860 miles

DRIVING APPROXIMATELY 35 MPH ON RESIDENTIAL COLLECTOR ROAD POWER STEERING FAILURE MESSAGE APPEARED AND STEERING WHEEL INSTANTLY BECAME ALMOST IMPOSSIBLE TO TURN. FORTUNATE ABLE TO WRESTLE STEERING AND TURN INTO RESIDENTIAL NEIGHBORHOODCOMING TO A COMPLETE STOP. TURNED CAR OFF TO INVESTIGATE ISSUE. UPON TURNING CAR BACK ON NO FAILURE LIGHT APPEARED AND NOW APPEARS OK TO DRIVE? IT WILL BE TAKEN TO SHOP FOR DIAGNOSTIC TESTING BUT LIKELY THIS IS THE ELECTRIC POWER STEERING UNIT. IF THIS HAPPENED SUDDENLY ON A A HIGHER SPEED TURN OR CURVE DRIFTING INTO ONCOMING TRAFFIC MORE THAN LIKELY. AN INABILITY TO STEER YOUR CAR JUST DRIVING DOWN THE ROAD WITH NO EXTERNAL EVENT IS A MAJOR SAFETY PROBLEM.

NHTSA complaint 11119424. Filed by an owner and not verified by NHTSA or by us.

73,000 miles

VEHICLES ELECTRONIC POWER STEERING CONTROL UNIT FAILED. VEHICLE WAS STATIONARY WHEN THIS HAPPENED, BUT BECAME INCREDIBLY DIFFICULT TO STEER. THIS APPEARS TO BE A COMMON ISSUE ON THESE CARS WITH SIMILAR MILEAGE (73,000). ACURA WILL NOT HONOR THE PART AND OWNERS HAVE TO PAY OUT OF POCKET FOR A COMMON SAFETY ISSUE.

NHTSA complaint 11064150. Filed by an owner and not verified by NHTSA or by us.