2010 CAN-AM Spyder RS

The defect

Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2012 Can-Am Spyder GS, RS, and RT series vehicles. The fuel cap may not fit onto the fuel tank filler neck, preventing it from sealing properly.

The risk

If the fuel cap does not seal properly, it may leak fuel vapors. Fuel vapors in the presence of an ignition source could result in a fire and personal injury.

The remedy

BRP will notify owners and send them a replacement fuel cap, free of charge. The safety recall is expected to begin in mid-January 2013. Owners may contact BRP AT 1-888-638-5397.

Bombardier Recreational Products Inc. · up to 33,700 vehicles across all model years covered

The defect

Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2009 Can-Am Spyder GS and model year 2010 Can-AM Spyder RS vehicles. Fuel vapors may exit the fuel vapor canister vent hose in the enclosed engine compartment.

The risk

Fuel vapors in the presence of an ignition source could result in a fire and personal injury.

The remedy

BRP will notify owners, and dealers will inspect the fuel vapor canister vent hose and replace and re-route it, as necessary, free of charge. The safety recall began on December 26, 2012. Owners may contact BRP AT 1-888-638-5397.

Bombardier Recreational Products Inc. · up to 9,600 vehicles across all model years covered

The defect

BRP IS RECALLING CERTAIN MODEL YEAR 2010 SPYDER RS SE5 2ND SERIES AND RT SE5 ROADSTERS. WHEN BRINGING A VEHICLE EQUIPPED WITH THE SE5 SEMI-AUTOMATIC TRANSMISSION TO A FULL STOP, THE CLUTCH MAY REMAIN ENGAGED STALLING THE ENGINE. ONCE THE ENGINE IS STALLED, IT COULD BE IMPOSSIBLE TO RE-START AND THE REAR WHEEL COULD BE BLOCKED.

The risk

IF THIS HAPPENS, THE VEHICLE MAY NOT BE ABLE TO BE PUSHED OFF THE ROADWAY INCREASING THE RISK OF A CRASH.

The remedy

BRP WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 7, 2010. OWNERS MAY CONTACT BRP AT 1-888-638-5397.

BOMBARDIER RECREATIONAL PRODUCTS INC. · up to 1,200 vehicles across all model years covered

crash · 26,000 miles

AS I WAS DRIVING MY SPYDER WOULDN'T SLOW DOWN AND I WAS AT 66MPH.. I DOWN SHIFTED AND IT STILL STAYED AT 66MPH. NO MATTER HOW MUCH I PRESSED ON THE BRAKE IT STAYED AT 66. LUCKY I HAD ENOUGH SENSE TO TURN THE BIKE OFF, BUT BY THEN I WAS IN THE WOODS BECAUSE I HAD TO AVOID HITTING OTHER CARS. MY POWER STEERING WASN'T WORKING AT THE TIME AND I CALLED BRP ON JULY 3 TO ASK THEM IF IT WAS STILL UNDER WARRANTY BECAUSE IT WAS REPLACED IN APRIL OF 2011. THEY TOLD ME IT WAS. SO I HAD THE ACCIDENT TWO WEEKS LATER NOW BRP WONT PAY FOR MY POWER STEERING UNIT. THEY SAID IT WAS DUE TO THE ACCIDENT EVEN THOUGH THEY HAVE NOTES ON ME CALLING IN ABOUT IT TWO WEEKS BEFORE THE ACCIDENT. MY BIKE IS ALWAYS IN THE …

NHTSA complaint 10543959, quoted in part. Filed by an owner and not verified by NHTSA or by us.

5,000 miles

I PURCHASED MY CAN-AM SPYDER IN 2013 IT WAS BRAND NEW. IT NOW ONLY HAS 5,000 MILES ON IT. I GOT THE DPS ERROR AND TOOK IT TO THE CAN-AM DEALER THEY SAID IT IS GOING TO COST ME 2500 TO GET IT FIX (AND THAT THIS ERROR ISN'T ONE THAT COULD BE PUT OFF). I ASKED IF IT IS COVERED BY WARRANTY OR A RECALL SYSTEM THEY SAID NO THAT MY VIN # DIDN'T FALL IN THAT CATEGORY. I LOOKED IT UP ON THE CAN-AM WEBSITE AND ALL THE WEBSITE SAYS IS THE MAKE AND MODEL AND YEAR OF THE RECALL NOT THAT IT IS LIMITED TO A VIN # RANGE.

NHTSA complaint 11000262. Filed by an owner and not verified by NHTSA or by us.

30,600 miles

ON SUNDAY, JULY 7, 2016, WHILE RIDING FROM OKLAHOMA CITY, OKLAHOMA TO TAOS, NEW MEXICO, I STOPPED FOR GASOLINE AT A GAS STATION SOMEWHERE IN NORTHEASTERN NEW MEXICO, POSSIBLY AROUND CLAYTON. WHEN I BEGAN TO UNSCREW THE GAS CAP, I HEARD A HISSING SOUND COMING FROM THE GAS TANK. THIS IS NOT UNUSUAL, AS THE GAS FREQUENTLY BOILS IN THE TANK, LIKELY DUE TO THE CLOSE PROXIMITY OF THE EXHAUST SYSTEM ON EACH SIDE OF THE FUEL TANK, BUT THIS TIME THE HISSING SOUNDED LIKE THE PRESSURE MAY HAVE BEEN HIGHER THAN NORMAL. I WENT AHEAD AND REMOVED THE GAS CAP, AT WHICH POINT GASOLINE AND/OR GAS VAPORS SPEWED OUT OF THE GAS TANK, KNOCKING THE GAS CAP FROM MY HAND AND HITTING ME IN THE FACE, NECK AND …

NHTSA complaint 10888403, quoted in part. Filed by an owner and not verified by NHTSA or by us.

25,074 miles

TOOK BIKE TO INTO BERT'S MEGAMALL IN AZUSA, CA. TO HAVE COOLANT TANK REPLACED AS FOUND COOLANT DRIP ON DRIVEWAY FIRST WEEK OF OCT 2013. HAD TO LEAVE BIKE SO THEY COULD ORDER PARTS. WAS CALLED BY SERVICE MGR. SEVERAL DAYS LATER AND WAS TOLD THAT THEY RAN VIN AND DPS SAFETY RECALL HAD NOT BEEN DONE AND COULD NOT RELEASE BIKE UNTIL DONE. I SAID IT WAS OK! TO DO RECALL. PICKED UP BIKE SEVERAL DAYS LATER AND TURN SIGNAL WOULDN'T CANCEL AFTER TURN. RETURNED TO DEALER. THEY HAD NOT ZEROED STEERING. FIXED! LEFT DEALER GOT ON FREEWAY AND WENT ABOUT 3MILES CLUSTER LIT UP AND BIKE WENT INTO LIMP MODE. RETURNED BIKE. MORE PARTS TO ORDER. SPARK PLUG WIRE GROUNDED TO HEAD. ANOTHER WEEK PICKED UP BIKE …

NHTSA complaint 10650514, quoted in part. Filed by an owner and not verified by NHTSA or by us.

5,150 miles

WHILE TRAVELING ON HIGHWAY AT APPX. 70 MPH, MY CRUISE CONTROL DROPPED OUT REDUCING VEHICLE SPEED TO SUCH A DEGREE TO BE A DANGER TO ME AND ANY FOLLOWING VEHICLES. I PULLED OFF THE HIGHWAY IN ATTEMPT TO DETERMINE PROBLEM; I WAS UNSUCCESSFUL. IT HAPPENED SEVERAL MORE TIMES SO I QUIT USING CRUISE CONTROL. DEALER LATER DETERMINED IT WAS THE HOUSING-SWITCH. IT IS OUT OF WARRANTY AND CAN-AM WON'T STAND BEHIND THE PRODUCT EVEN THOUGH IT HAS LESS THAN 6000 MILES ON IT. I BELIEVE PART IS DEFECTIVE. *TR

NHTSA complaint 10514316. Filed by an owner and not verified by NHTSA or by us.

4,670 miles

THE VSS FAULT LIGHT CAME ON AND THE ENGINE BEGAN RUNNING ROUGH AS IF IT WAS NOT HITTING ON ALL SPARK PLUGS WHEN I WENT INTO A TURN. I PULLED OVER AND SHUT OFF THE ENGINE, WAITED A FEW MINUTES, AND RESTARTED THE VEHICLE. THIS ALLOWED THE COMPUTER TO REBOOT. THIS HAS OCCURRED THREE TIMES SINCE. LATER, MY FRONT TRUNK RELEASE BUTTON QUIT WORKING AND THE RIGHT FOG LIGHT QUIT WORKING (BULB IS FUNCTIONAL) AND MY GAS MILEAGE HAS GONE DOWN. I HAD NONE OF THESE PROBLEMS UNTIL THE DYNAMIC POWER STEERING UNIT WAS REPLACED DURING A RECALL. *TR

NHTSA complaint 10442360. Filed by an owner and not verified by NHTSA or by us.