2010 CAN-AM Spyder RT

The defect

Bombardier Recreational Products Inc. (BRP) is recalling certain model year 2008-2012 Can-Am Spyder GS, RS, and RT series vehicles. The fuel cap may not fit onto the fuel tank filler neck, preventing it from sealing properly.

The risk

If the fuel cap does not seal properly, it may leak fuel vapors. Fuel vapors in the presence of an ignition source could result in a fire and personal injury.

The remedy

BRP will notify owners and send them a replacement fuel cap, free of charge. The safety recall is expected to begin in mid-January 2013. Owners may contact BRP AT 1-888-638-5397.

Bombardier Recreational Products Inc. · up to 33,700 vehicles across all model years covered

The defect

BOMBARDIER RECREATIONAL PRODUCTS INC. (BRP) IS RECALLING CERTAIN MODEL YEAR 2010 SPYDER RT ROADSTERS. A PIN SECURING THE BRAKE PEDAL CONNECTING ROD COULD DISENGAGE AND FALL OFF.

The risk

IF THIS OCCURS, A TOTAL LOSS OF MAIN BRAKE FUNCTION COULD RESULT WITHOUT PRIOR WARNING. THERE IS AN INCREASED RISK OF A CRASH POSSIBLY RESULTING IN INJURY OR DEATH.

The remedy

BRP WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE BRAKE PEDAL CONNECTING ROD PINS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 18, 2012. OWNERS MAY CONTACT BRP AT 1-888-638-5397.

BOMBARDIER RECREATIONAL PRODUCTS INC. · up to 3,259 vehicles across all model years covered

The defect

BRP IS RECALLING CERTAIN MODEL YEAR 2010 SPYDER RS SE5 2ND SERIES AND RT SE5 ROADSTERS. WHEN BRINGING A VEHICLE EQUIPPED WITH THE SE5 SEMI-AUTOMATIC TRANSMISSION TO A FULL STOP, THE CLUTCH MAY REMAIN ENGAGED STALLING THE ENGINE. ONCE THE ENGINE IS STALLED, IT COULD BE IMPOSSIBLE TO RE-START AND THE REAR WHEEL COULD BE BLOCKED.

The risk

IF THIS HAPPENS, THE VEHICLE MAY NOT BE ABLE TO BE PUSHED OFF THE ROADWAY INCREASING THE RISK OF A CRASH.

The remedy

BRP WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 7, 2010. OWNERS MAY CONTACT BRP AT 1-888-638-5397.

BOMBARDIER RECREATIONAL PRODUCTS INC. · up to 1,200 vehicles across all model years covered

The defect

BOMBARDIER RECREATIONAL PRODUCTS, INC. (BRP) IS RECALLING MODEL YEAR 2010 ROADSTER SPYDER RT SM5 AND SE5 MOTORCYCLES MANUFACTURED BETWEEN OCTOBER 13 AND OCTOBER 30, 2009. THE CONNECTOR ON THE KEY SWITCH HARNESS MAY NOT BE LOCKED AND THE IGNITION SWITCH HARNESS MAY BE ROUTED TOO TIGHT. IN SOME SITUATIONS, THE CONNECTOR MAY UNPLUG.

The risk

IF THIS OCCURS, THE VEHICLE MAY STALL WITHOUT WARNING AND COULD POTENTIALLY CAUSE A CRASH.

The remedy

BRP WILL NOTIFY OWNERS AND AUTHORIZED DEALERS WILL INSPECT TO ENSURE THAT THE CONNECTOR IS LOCKED AND THAT THE IGNITION SWITCH HARNESS IS NOT ROUTED TOO TIGHT AND CORRECT THE HARNESS IF NEEDED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 18, 2009. OWNERS MAY CONTACT BRP AT 1-888-638-5397 OR 1-819-566-3366.

BOMBARDIER RECREATIONAL PRODUCTS INC. · up to 108 vehicles across all model years covered

15,000 miles

The contact owns a 2010 Can-Am Spyder RT. The contact stated while driving 55 MPH, the steering wheel became firm. The power steering and parking brake warning lights were illuminated. The vehicle had not been diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure and stated that the vehicle was not included in a recall. The failure mileage was approximately 15,000.

NHTSA complaint 11545404. Filed by an owner and not verified by NHTSA or by us.

10,000 miles

POSSIBLE DPS FUME CANISTER CONCERN ON RECALL. FUEL CAP SEEMS TO ALLOW WATER INSIDE OF THE FUEL TANK? WHICH THEN CAUSES THE BIKE TO SPUTTER AND NOT WANT TO "BREATH." WHEN THE BIKE IS WARMING UP, IT'S SPITTING AND SPUTTERING, DOES NOT WANT TO IDLE PROPERLY.

NHTSA complaint 11235018. Filed by an owner and not verified by NHTSA or by us.

14,000 miles

TL* THE CONTACT OWNS A 2010 CAN-AM ROADSTER SPYDER RTSM5. WHILE DRIVING APPROXIMATELY 30 MPH, THE DYNAMIC POWER STEERING AND LIMP HOME MODE WARNING LIGHTS ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V162000 (STEERING). THE FAILURE MILEAGE WAS 14,000.

NHTSA complaint 10722855. Filed by an owner and not verified by NHTSA or by us.

15,000 miles

TL* THE CONTACT OWNS A 2010 CAN-AM SPYDER RT. UPON STARTING UP THE MOTORCYCLE, A FAILURE OCCURED IN WHICH THE THE AIR BAG FOR THE SUSPENSION OVER INFLATED. THE CONTACT STATED THAT THE POSITION SENSOR FAILED CAUSING THE AIR BAG TO FILL TO CAPACITY WITHOUT WARNING AND OTHER COMPONENTS FAILED ASSOCIATED WITH THE SUSPENSION. THE MOTORCYCLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT IF THE MANUFACTURER APPROVED THE MODIFICATION, THERE NEEDED TO BE AN INSTALLATION OF A RELEASE VALVE. THE MANUFACTURER'S TECHNICIAN STATED THAT A RELEASE VALVE WAS NOT PART OF THE DESIGN FOR THIS MODEL AND WAS AWARE THAT THE SENSOR FAILURE CAUSED THE AIR COMPRESSOR TO RECEIVE MORE AIR THAN NECESSARY WHICH …

NHTSA complaint 10715177, quoted in part. Filed by an owner and not verified by NHTSA or by us.

21,000 miles

AT RANDOM TIMES, THE POWER STEERING GOES OUT ON THE SPYDER WITH NO WARNING. IT DOESN'T SHOW ANY CODES WHEN IT HAPPENS. DOESN'T MATTER IF IT'S ON A STRAIGHT STRETCH OR CURVE. DIFFICULTY TURNING THE WHEELS WHEN THIS HAPPENS. *TR

NHTSA complaint 10626682. Filed by an owner and not verified by NHTSA or by us.

EXTREME HEAT ON THE RIGHT SIDE NEAR MY FEET. INSTALLED FANCAN, WITH NO RESULT. ALSO, HEAT IS EXPERIENCED AROUND THE SEAT. *TR

NHTSA complaint 10626680. Filed by an owner and not verified by NHTSA or by us.