2012 Mitsubishi I-Miev

The defect

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2012-2017 i-MiEV vehicles. Water may penetrate the brake assist vacuum pump, causing corrosion and a failure of the brake vacuum pump.

The risk

Without the brake vacuum pump, the driver will experience a sudden loss of braking assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.

The remedy

MMNA will notify owners, and dealers will replace the brake vacuum pump, free of charge. The recall began January 7, 2020. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-19-002.

Mitsubishi Motors North America, Inc. · up to 2,108 vehicles across all model years covered

The defect

Mitsubishi Motors North America, Inc. (MMNA) is recalling certain 2012 and 2014 i-MiEV vehicles. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

The risk

An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

The remedy

MMNA will notify owners, and dealers will replace the front passenger air bag inflator, free of charge. The recall began on March 10, 2017. Owners may contact MMNA customer service at 1-888-648-7820. MMNA's number for this recall is SR-17-001.

Mitsubishi Motors North America, Inc. · up to 1,964 vehicles across all model years covered

The defect

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2014 Mitsubishi Mirage vehicles manufactured July 27, 2013, to November 20, 2013, and 2012 Mitsubishi i-MiEV vehicles manufactured October 28, 2011, to September 7, 2012. Due to an increased resistance in the impact sensor for the air bag system, in the event of a crash necessitating deployment of the frontal, side and/or curtain air bags when the SRS warning is illuminated, the frontal air bag may have a delayed deployment and/or the side and curtian air bag may not deploy at all.

The risk

In the event of a crash, an air bag that does not deploy or deploys late, increases the risk of occupant injury.

The remedy

Mitsubishi will notify owners, and dealers will replace the affected impact sensors, free of charge. The recall began on November 5, 2015. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-15-011.

Mitsubishi Motors North America, Inc. · up to 13,558 vehicles across all model years covered

The defect

Mitsubishi Motors North America, Inc. (Mitsubishi) is recalling certain model year 2010-2014 i-MiEV electric vehicles manufactured September 15, 2009, to March 25, 2014. Due to either software programming or corrosion caused by road salt, the brake vacuum pump may stop functioning.

The risk

If the brake vacuum pump stops functioning, the distance needed to stop the vehicle may be lengthened, increasing the risk of a crash.

The remedy

Mitsubishi will notify owners, and depending on the affected vehicle, dealers will either reprogram the brake vacuum pump controller, replace the brake vacuum pump or do both, free of charge. The recall began on October 24, 2014. Owners may contact Mitsubishi customer service at 1-888-648-7820. Mitsubishi's number for this recall is SR-14-007.

Mitsubishi Motors North America, Inc. · up to 1,810 vehicles across all model years covered

The defect

Mitsubishi Motors North America is recalling certain model year 2012 i-MiEV electric vehicles manufactured December 2, 2011, through September 7, 2012. The brake system vacuum pump may fail, causing the vacuum pump to be inoperable.

The risk

If the vaccum pump system fails, it will reduce available brake power which would result in lengthened stopping distances, which may increase the risk of a vehicle crash.

The remedy

Mitsubishi will notify owners, and dealers will replace the affected vacuum pumps free of charge. The recall began on February 28, 2013. Owners may contact Mitsubishi at 1-888-648-7820.

Mitsubishi Motors North America, Inc. · up to 1,402 vehicles across all model years covered

The defect

Mitsubishi is recalling certain model year 2012 i-MiEV vehicles manufactured between November 4, 2011, and December 22, 2011. Incompatibility between the air bag sensors and the self-diagnostic software may deactivate the frontal and side airbag system. Should this occur, the SRS warning lamp would illuminate to alert the driver.

The risk

The side and curtain air bags may not deploy in a crash for which those air bags were intended to deploy, increasing the risk of personal injury to the vehicle occupants.

The remedy

Mitsubishi will notify owners, and dealers will replace the incompatible air bag sensors with new, compatible units, free of charge. The safety recall began on during August 2012. Owners may contact Mitsubishi at 1-800-222-0037.

MITSUBISHI MOTORS NORTH AMERICA, INC. · up to 261 vehicles across all model years covered

Closed recall query · opened May 10, 2019 · closed December 12, 2019 · led to recall 19V804000

the brakes, the hydraulic brakes

On May 10, 2019, the Office of Defects Investigation (ODI) opened Recall Query RQ19-002 to investigate three complaints alleging brake vacuum pump failures after the remedies for Recalls 13V-031 and 14V-522 had been completed in model year (MY) 2012 Mitsubishi i-MiEV vehicles. The investigation was opened on model year (MY) 2010 through 2017 Mitsubishi i-MiEV vehicles to cover all products sold in the United States with the same vacuum pump (Recall 14V-522 included MY 2010 through 2014 i-MiEV vehicles). Mitsubishi Motors North America, Inc. (MMNA) provided information about nine (9) additional reports of brake vacuum pump failure in its response to ODI's information request letter for RQ-002 (MY 2012 - 8, MY 2014 - 1). In addition, MMNA's response indicated that there are no MY 2010 through 2011 i-MiEV vehicles currently in the United States (a small number of MY 2010 through 2011 pre-production i-MiEV demo vehicles were listed as scrapped or exported - four of these were included in the scope of 14V-522).On November 8, 2019, MMNA submitted a Defect Information Report (DIR) to NHTSA describing a defect in the brake vacuum pump in approximately 2,108 MY 2012 through 2017 Mitsubishi i-MiEV vehicles manufactured from October 28, 2011 through June 10, 2016 (NHTSA Recall 19V-804, Mitsubishi Recall SR-19-002). Mitsubishi's DIR identified a defect in the brake vacuum pump design that may allow water to penetrate the pump and cause internal corrosion, which may result in brake vacuum pump failure and increased risk of a vehicle crash. Recalled vehicles will have the vacuum pump replaced with a redesigned pump that has improved sealing and anti-corrosion performance.Mitsubishi's DIR indicates that the recall covers all i-MiEV vehicles sold in the United States, as U.S. sales began with MY 2012 and concluded with MY 2017.This investigation is closed based on Recall 19V-804. The ODI reports cited above can be reviewed at NHTSA.gov under the following ID numbers:11078966, 11171175, 11187483.

Takata Recall. The contact owns a 2012 Mitsubishi I-MIEV. The contact received notification of NHTSA campaign numbers: 19V804000 (Service, Brake, Hydraulic), 17V022000 (Air Bags), and 15V594000 (Air Bags) however, the contact stated there was no local dealer in their area to do the recall repairs. When they reached out to the manufacturer, they were informed to find a local authorized dealer, when the contact found an independent mechanic to do the recall repairs, the manufacturer would not authorize the independent mechanic to do the recall repairs. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of …

NHTSA complaint 11421884, quoted in part. Filed by an owner and not verified by NHTSA or by us.

89,804 miles

MITSUBISHI ANNOUNCED A RECALL FOR ON BOARD CHARGER (OBC) DEFECTS PER ATTACHED LETTER AND ADVISED REPLACEMENT OR REFUND IF PART WAS ALREADY REPLACED. ALSO ATTACHED REPAIR INVOICE 301408 FOR $5080.82 WAS PAID BY WARRANTY COMPANY. MITSUBISHI IS OFFERING REFUND OF $100.00 DEDUCTIBLE INSTEAD OF TOTAL COSTS. PLEASE INTERVENE TO GET THE COMPLETE REFUND FROM OEM.

NHTSA complaint 11319835. Filed by an owner and not verified by NHTSA or by us.

60,000 miles

ON MULTIPLE OCCASIONS VEHICLE WILL ACCELERATE AT HALF CHARGE UNDER LOAD WILL DEACCELERATE FROM 50 TO BELOW 30 MILES AN HOUR. CAUSING DISRUPTIONS IN TRAFFIC AND PEOPLE PASSING YOU. THE POWER STEERING SEEMS TO SHUT DOWN WITH THE TURTLE LIGHT.

NHTSA complaint 11311628. Filed by an owner and not verified by NHTSA or by us.

TL* THE CONTACT OWNS A 2012 MITSUBISHI I-MIEV. THE CONTACT STATED THAT THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V804000 (BRAKE ASSIST VACUUM PUMP). THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE WAS TAKEN TO OAKLAND KIA MITSUBISHI, 2424 WEBSTER STREET, OAKLAND, CA 94612 WHERE THE MECHANIC CONFIRMED THAT THE PARTS WOULD NOT BE AVAILABLE FOR FOUR MONTHS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

NHTSA complaint 11307038. Filed by an owner and not verified by NHTSA or by us.

22,141 miles

TL* THE CONTACT OWNS A 2012 MITSUBISHI I-MIEV. AFTER THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 14V522000 (SERVICE BRAKES, HYDRAULIC), THE BRAKE PRESSURE BEGAN LOSING POWER. IN ADDITION, THE BRAKE INDICATOR ILLUMINATED INTERMITTENTLY. THE CONTACT CALLED SIMS MITSUBISHI (2908 MEDINA RD, MEDINA, OH 44256, (330) 722-8000) AND WAS INFORMED TO BRING THE VEHICLE IN FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,141.

NHTSA complaint 11187483. Filed by an owner and not verified by NHTSA or by us.

50,000 miles

ON 11/20/18, WE TOOK OUR 2012 I-MIEV INTO THE ROGER BEASLEY MITSUBISHI AT 1120 SHELBY LN, AUSTIN, 78745 AFTER THE CAR RAPIDLY LOST POWER WHILE DRIVING AT HIGHWAY SPEEDS ON AT LEAST 2 OCCASIONS. THE FIRST TIME HE WAS DRIVING 65 MPH AND THE CAR SLOWED TO ABOUT 15 MPH. THE OUTDOOR TEMPERATURE WAS 50 DEGREES. HE IMMEDIATELY PULLED OVER AND TURNED THE CAR OFF. HE RESTARTED IT TO SEE IF HE COULD GET THE CAR HOME. THE CAR STARTED. HE WAS ABLE TO GET IT UP TO 58 MPH AND ONCE AGAIN IT SUDDENLY LOST POWER AND DROPPED TO 15 MPH. WHEN THE CAR SLOWED TO 15 MPH, THE DASHBOARD DISPLAYED AN EXCLAMATION MARK INSIDE OF A CAR ERROR LIGHT. HE TOOK A VIDEO OF THE 2ND OCCURRENCE: NOTE THAT THE CAR HAD 24 MI …

NHTSA complaint 11171524, quoted in part. Filed by an owner and not verified by NHTSA or by us.