2014 Audi S7

The defect

Volkswagen Group of America, Inc. (Audi) is recalling certain 2013-2017 A8, S6 Sedan, S7, S8, and 2014-2017 RS7 vehicles. The turbocharger oil supply strainer can become blocked, causing wear to the bearings due to lack of lubrication.

The risk

Worn bearings can cause the turbine wheel to contact the turbocharger housing or cause the shaft to break, causing an engine stall and increasing the risk of a crash.

The remedy

Dealers will replace the oil strainer and perform an oil change, free of charge. Owner notification letters were mailed August 4, 2022. Owners may contact Audi customer service at 1-800-253-2834. Audi's number for this recall is 21H7.

Volkswagen Group of America, Inc. · up to 26,093 vehicles across all model years covered

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2013-2018 Audi S6 and S7, 2012-2018 A7 and A6 Sedan, and 2014-2018 RS7 vehicles equipped with basic seats (with or without heating). Stress or wear of the body-sensing mat within the front passenger seat may cause the Passenger Occupant Detection System (PODS) control module to malfunction.

The risk

If the PODS module malfunctions, the front passenger air bag may not deploy properly in the event of a crash, increasing the risk of injury.

The remedy

Volkswagen will notify owners, and dealers will install a PODS system repair kit, free of charge. The recall began November 29, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 74D5.

Volkswagen Group of America, Inc. · up to 139,249 vehicles across all model years covered

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2014-2015 Audi S7 and 2016-2018 RS7 vehicles. The tire information label on these vehicles incorrectly lists the combined maximum weight as 1146 lbs/520 kg, when the correct combined maximum weight is actually 992 lbs/450 kg. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."

The risk

If the operator were to load the vehicle based on information on the tire information label, they could overload the vehicle, increasing the risk of a crash.

The remedy

Audi will notify owners, and dealers will replace the tire information label, free of charge. The recall began on March 9, 2018. Owners may contact Audi customer service at 1-800-253-2834. Volkswagen's number for this recall is 44N9.

Volkswagen Group of America, Inc. · up to 3,543 vehicles across all model years covered

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2013-2014 Audi S6 and S7 vehicles equipped with 4.0L engines. Due to manufacturing tolerance issues, a fuel line may leak fuel.

The risk

A fuel leak, in the presence of an ignition source, may result in a fire.

The remedy

Volkswagen will notify owners, and dealers will replace the fuel line, free of charge. The safety recall is planned to begin in late October 2013. Owners may contact Audi of America at 1-800-822-2834. Volkswagen's number for this campaign is 20U6/L8.

Volkswagen of America, Inc. · up to 3,594 vehicles across all model years covered

Closed engineering analysis · opened April 4, 2022 · closed May 26, 2023

the engine and its cooling

On March 29, 2021, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE 21-009) after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7 equipped with the 4.0L, twin-turbocharged engine. Complainants reported the vehicles would stall with no warning while driving at highway or city traffic speeds. Several of the complainants alleged an inability to restart. The complaints alleged the major contributing factor to the engine stalling was the failure of the turbochargers. The complaints cited the turbocharger failure was a result of oil starvation due to a clogged oil strainer in the turbocharger oil supply line.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making servicing the component difficult. The oil strainer removes particles and carbon deposits from the oil before lubricating the turbochargers. Over time, if the debris is not removed from the oil strainer, it becomes clogged and prevents oil from flowing to the turbochargers. This causes the turbine bushings to run dry and overheat resulting in turbine shaft failure due to thermal stress.On April 04, 2022, PE21-009 was upgraded to an Engineering Analysis (EA22-001) to further assess the scope, frequency, and potential safety related consequences of the alleged defect. Volkswagen filed recall 22V-178 to replace the 30?m mesh oil strainer with a 90?m mesh oil strainer in the subject vehicles. VW introduced the larger mesh oil strainer into production in March of 2017 effecting the 2017-2018MY vehicles.ODI reviewed information from VW for vehicles that had the larger mesh installed in production. The data received showed, since the new oil strainer size of 90?m went into production for the 2017-2018MY, there has not been any reported incidents of turbocharger failures due to oil starvation or other failures that could be related to the larger screen mesh. In view of the recall being conducted by VW and lack of any detrimental side effect to the turbocharger caused by the larger mesh, ODI is closing this Engineering Analysis (EA). The agency reserves the right to take additional action if warranted by future circumstances.11502847,11506565,11494663,11488813,11486393,11480926,11479882,11476289,11466761 11464663,11463254,11460580,11460496,11458973,11458804,11457556,11454753,11452668 11452589,11452584,11452383,11452175,11452111,11451724,11451724,11450995,11450988 11449661,11447092,11443657,11442867,11440536,11440052,11439959,11438691,11436461 11435619,11433925,11433733,11432336,11431661,11431421,11429704,11429584,11428128 11426929,11424203,11423603,11423337,11422431,11421084,11420626,11420342,11419693 11418884,11418437,11418433,11418135,11417635,11417351,11416095,11414578,11414235 11414064,11413359,11413285,11413214,11407510,11407450,11406897,11406821,11406637 11406460,11406416,11406291,11406287,11406277,11406273,11406263,11406256,11406251 11406229,11406222,11406208,11406204,11406197,11406182,11406015,11404665,11404426 11404348,11403823,11403430,11403268,11402684,11399435,11397821,11396241,11394763 11391037

Closed preliminary evaluation · opened March 29, 2021 · closed May 27, 2022 · led to recall 22V178000

the engine and its cooling

On March 29, 2021, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) 21-009 after the agency received 58 reports alleging engine stalling in 2013-2016MY Audi vehicle models A8, S6, S7, S8 & RS7. The subject vehicles are equipped with 4.0L, twin-turbocharged engine. Complainants reported that the vehicles stall suddenly with no warning while driving on the highway or in city traffic. Several of the complainants alleged an inability to restart. The complaints allege the major contributing factor to the engine stalling is the failure of the turbochargers. The complaints further allege the turbocharger failure is a result of oil starvation due to a clogged oil strainer.The location of the oil strainer in the turbocharger oil supply line is in the inner valley of the engine. It is not easily accessible, making regular service difficult. The oil strainer removes dirty particles and carbon deposits from the oil before flowing to lubricate the Turbochargers. Overtime if the debris are not removed from the oil strainer, it clogs the strainer and prevents free flow of oil to the turbochargers and makes the turbine bushings to run dry and overheat which causes the turbine shaft to break due to thermal stress. In VW's response to ODI's Information Request letter, VW provided approximately 611 warranty claims with unique VINs, 70 Field Reports and 45 Consumer complaints. These reports allege engine stalling due to turbocharger failure similar to the NHTSA reports described above. To date, NHTSA has received approximately 98 allegations of stall due to turbocharger failures. The total of 824 reports shown in the table above eliminates duplicate reports received by both ODI and the manufacturer.This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA) to further assess the scope, frequency, and potential safety related consequences of the alleged defect of engine stalling due to turbocharger failureThe ODI complaints cited above can be viewed at www.NHTSA.gov under the following ODI identification numbers:11452589, 11452584, 11452383, 11450995, 11450988, 11449661, 11447092, 11442867 11440536, 11440052, 11439959, 11438691, 11436461, 11435619, 11431661, 11429704 11429584, 11426929, 11424203, 11423603, 11423337, 11421084, 11420626, 11420342 11418884, 11418437, 11418433, 11417635, 11417351, 11416095, 11414235, 11413359 11413214, 11413285, 11413133, 11407510, 11407450, 11407289, 11406821, 11406416 11406291, 11406277, 11406273, 11406256, 11406251, 11406229, 11406222, 11406204 11406197, 11406182, 11404665, 11404426, 11404348, 11403430, 11403268, 11399435 11397821, 11396241, 11394763, 11391037, 11388662, 11387166, 11377446, 11363283 11354107, 11344193, 11342497, 11342360, 11340302, 11325065, 11324163, 11322168, 11321144, 11318477, 11306754, 11279429, 11268109, 11256706, 11252723, 11246579 11234853, 11234714, 11231582, 11231013, 11230589, 11229484, 11222281, 11218822 11218749, 11217604, 11209168, 11209142, 11197149, 11191243, 11175842, 11170776 11164032, 11152418.

towed · 70,500 miles

The contact owns a 2014 Audi S7. The contact stated while driving 40 MPH, the vehicle stalled without warning. The contact pulled over but was unable to restart the vehicle. The vehicle was towed to a local dealer to be diagnosed but was not repaired. The contact stated there was no warning light illuminated. The manufacturer was not informed of the failure. The failure mileage was approximately 70,500.

NHTSA complaint 11432336. Filed by an owner and not verified by NHTSA or by us.

towed · 118,000 miles

The contact owns a 2014 Audi S7. The contact stated while driving approximately 30 MPH, the vehicle inadvertently stopped. Additionally, the vehicle was leaking an excessive amount of oil. There was an EPC warning light illuminated. The vehicle was towed to the local dealer however, the mechanic was unable to determine the cause of the failure. The contact related the failure to NHTSA Campaign Number: 22V178000 (Engine and Engine Cooling). The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 118,000.

NHTSA complaint 11466761. Filed by an owner and not verified by NHTSA or by us.

The ECU control module Is a known problem with this car by a great amount of owners. It is such a problem that the car part is on back order for weeks at a time. The biggest issue about this is that the car just randomly doesn’t turn on and randomly shuts down on the roads, freeways and even U turns. It can potentially lead to critical injuries

NHTSA complaint 11643934. Filed by an owner and not verified by NHTSA or by us.

The adaptive cruise control and Brake asist features are only working occasionally. Some times it switches on and off DURING traffic while the car is moving. This is a severe saftey issue IMO and needs to be taken care of by Audi.

NHTSA complaint 11461069. Filed by an owner and not verified by NHTSA or by us.

Acc audi breaking guard fault lane assistance malfunction.

NHTSA complaint 11427861. Filed by an owner and not verified by NHTSA or by us.

System malfunction acc and breaking guard

NHTSA complaint 11427951. Filed by an owner and not verified by NHTSA or by us.