2016 Toyota Prius C

Closed defect petition · opened January 27, 2023 · closed August 7, 2023 · led to recall 22V063000

the electrical system

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

towed · 7,000 miles

TL* THE CONTACT OWNS A 2016 TOYOTA PRIUS C. WHILE DRIVING VARIOUS SPEEDS, A RUBBER ODOR EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER, BUT NO FAILURE WAS DETERMINED. SEVERAL DAYS LATER, THE "HYBRID COOLANT SYSTEM NEEDS SERVICE" WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED AS A SAFETY HAZARD. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNABLE TO BE DRIVEN AND THAT THE BATTERY COMPARTMENT FILTER SYSTEM NEEDED CLEANING TO PREVENT THE BATTERIES FROM OVERHEATING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 7,000.

NHTSA complaint 10935533. Filed by an owner and not verified by NHTSA or by us.

P 175/65r15 I was driving on a slight curve on the I-10 in El Paso, TX when the rear bumper exploded. The car started swaying and swerving then I pulled over. I then realized that the tread on the tire was gone floating across the highway. The trie was bare with no tread with the bumper around the tire was gone. The explosion also caused the tail light to break.

NHTSA complaint 11681053. Filed by an owner and not verified by NHTSA or by us.

See attached document for complaint

NHTSA complaint 11609943. Filed by an owner and not verified by NHTSA or by us.

Prinx HiCITY HH2 175/65R15 84H Bought this tire in November 2022. About 15000 miles into it, on Aug 6, 2024, the passenger front tire just busted. After swapping with the spare tire, and upon inspection, there was no nail nor it hit the curb, but the side wall is busted. This is a manufacturing quality issue.

NHTSA complaint 11607627. Filed by an owner and not verified by NHTSA or by us.

The original windshield has a “rippling distortion” where the windshield has ripple/bubble from defective glass or installation mistakes, making seeing traffic signs or streets very hard. I just bought this vehicle and noticed the problem. It created poor road vision, especially at night. Toyota needs to recall and replace all these windshields before it causes more accidents due to poor visibility looking through the glass.

NHTSA complaint 11490244. Filed by an owner and not verified by NHTSA or by us.

WHEN I AM IN THE PROCESS OF BRAKING AND HIT A ROUGH SPOT IN THE ROAD SUCH AS A POTHOLE, I ESSENTIALLY LOSE CONTROL OF THE CAR FOR A SPLIT SECOND. IT FEELS JERKY LIKE IT LURCHES FORWARD OR SHAKES SIDE TO SIDE. ITS NOT VERY PRONOUNCED BUT ENOUGH TO MAKE ME FEEL UNSAFE. THIS HAPPENS EVERY TIME I AM BRAKING AND RUN OVER POTHOLES, SO ITS NOT AN ISOLATED INCIDENT THAT ONLY HAPPENED ON ONE DAY, AND IT DOESN'T MATTER HOW HARD I'M BRAKING OR HOW FAST I'M GOING UNLESS I'M BARELY MOVING (THEN IT DOESN'T JERK).

NHTSA complaint 11181608. Filed by an owner and not verified by NHTSA or by us.

19,700 miles

SINCE PURCHASE OF THE CAR, THE VEHICLE HAS SHIFTED FROM DRIVE TO NEUTRAL UPON BRAKING HARD. THIS HAS OCCURRED WHILE DRIVING ON THE FREEWAY. THE CAR WILL NOT RETURN TO DRIVE WITHOUT TURNING OFF THE ENGINE AND RESTARTING. IT IS NOT SAFE TO DRIVE. TOYOTA OF CARLSBAD COULDN'T REPRODUCE THE EVENT AFTER A FEW TRIES ON A TEST DRIVE, SO THEY WILL NOT DO ANYTHING ABOUT IT. I AM CONCERNED ABOUT HAVING A FATAL ACCIDENT WHILE DRIVING ON THE FREEWAY. THE EVENTS HAPPEN RANDOMLY.

NHTSA complaint 11055096. Filed by an owner and not verified by NHTSA or by us.