2019 MINI Cooper

The defect

BMW of North America, LLC (BMW) is recalling certain 2018-2019 BMW X1 sDrive28i, X1 xDrive28i, 2019 X2 xDrive28i, MINI Cooper S Convertible, Countryman, and John Cooper Works Countryman vehicles. The steering gear tie rod may have been assembled incorrectly, which may result in excessive wear of the tie rod end, eventually causing it to break.

The risk

A broken steering tie rod would lead to a loss of vehicle control, increasing the risk of a crash.

The remedy

BMW will notify owners, and dealers will inspect the vehicles and replace the tie rods and ball joints as necessary, free of charge. The recall began October 11, 2019. Owners may contact BMW customer service at 1-800-525-7417 or MINI customer service at 1-866-825-1525.

BMW of North America, LLC · up to 32 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2018 BMW 540d xDrive vehicles. The crankshaft sensor may be equipped with incorrect firmware, preventing the sensor from properly processing input from the crankshaft reluctor ring, possibly resulting in a vehicle stall. On September 12, 2018, BMW expanded the recall to a total of 5,309 vehicles including certain 2018-2019 BMW 540d xDrive, 230i M240i, M240i xDrive, X2 sDrive28i, X2 xDrive28i, X1 sDrive28i, X1 xDrive28i, 330i, 330i xDrive, 340i, 340i xDrive, 330i xDrive Gran Turismo, 530i, 530i xDrive, 540i, 540i xDrive, 530e, 530e xDrive, 640i xDrive Gran Turismo, 330e, 2019 430i Gran Coupe, 430i xDrive Gran Coupe, 440i Gran Coupe, 440i xDrive Gran Coupe, 430i, 430i xDrive, 440i, 440i xDrive, 740i, 740i xDrive, MINI Cooper, Cooper S, JCW, MINI Countryman (Cooper, Cooper All4, Cooper S, Cooper S All4, JCW All4), and MINI Clubman (Cooper, Cooper S, Cooper All4, Cooper S All4, JCW All4) vehicles.

The risk

A vehicle stall can increase the risk of a crash.

The remedy

BMW will notify owners, and dealers will replace the crankshaft sensor, free of charge. The recall began September 6, 2018. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 5,309 vehicles across all model years covered

Certain 2019 MINI and BMW models are equipped with older evaporators that are not lined correctly to prevent aluminum corrosion from the new R-1234yf refrigerant, causing premature leaks of the refrigerant into the cabin while driving. Exposure to the refrigerant can cause severe irritations including dizziness, sudden and uncontrollable pain in the eyes and bursts of tears while driving. This has happened to me multiple times, until I stopped using AC completely.

NHTSA complaint 11718564. Filed by an owner and not verified by NHTSA or by us.

I’ve been experiencing headaches, dizziness, and sudden tearing episodes while driving and the tearing only happens while driving my MINI. A few of these episodes have occurred on the highway, the painful eye irritation and crazy tearing made it very difficult to keep my eyes open, which has been super dangerous. I forced myself to keep at least one eye open to pull over, and fortunately I'm still alive. I recently found that these symptoms are probably linked to the premature failure (at 10k miles) of the AC system and exposure to the refrigerant leaked from the vent. I noticed AC hissing noise a few days after my warranty expired at only 10k miles, the dealer found super low refrigerant …

NHTSA complaint 11688267, quoted in part. Filed by an owner and not verified by NHTSA or by us.

my vehicle only has 23000 how is it that vehicle with low miles and 5 yrs old and there telling me that engine mounts are cracked what mini cooper said was that the reason why is because there made out of plastic . how can this be legal what holds the engine in place made from plastic ? i think this need to be investigated and looked into is not safe and is not fair to the consumer to have to pay for this bad choice in design .

NHTSA complaint 11583487. Filed by an owner and not verified by NHTSA or by us.

Car sent a message about vehicle stabilization initiation in the middle of the road. I could barely turn the steering wheel and change the lane. Authorized dealer service center tells me it’s a click and drive wiring malfunction issue. I was on the way to the airport via toll road and highway. Continue to drive with the stabilization in progress could caused me an accident for not being able to move the wheel smoothly.

NHTSA complaint 11554951. Filed by an owner and not verified by NHTSA or by us.

*The condensate drain hose is not properly draining the condensate from the vehicle. *Breathing in mold and didn't know it *Yes the problem was confirmed by the dealer *The dealer inspected *no warnings, no recalls

NHTSA complaint 11552302. Filed by an owner and not verified by NHTSA or by us.

I am writing regarding the failure of the steering column on my 2019 Mini Cooper Hardtop. The incident occurred on December 31, 2022. I drove my car to a residential location in Seattle, parked and locked the vehicle. When I returned to my car and started it up to move it, I realized I had no control of the car because the steering wheel was spinning uncontrollably. When the car was towed to Seattle Mini, the AAA tow truck driver and the dealership service department personnel receiving the car said they had seen nothing like this before. Seattle Mini takes the position that the steering column was forcibly broken due to an accident which is not the case. I’m very concerned about the safety …

NHTSA complaint 11501907, quoted in part. Filed by an owner and not verified by NHTSA or by us.