2022 BMW R 18

The defect

BMW of North America, LLC (BMW) is recalling certain 2021-2024 BMW R18 motorcycles. The seal for the reverse gear control unit may deteriorate and allow moisture inside the control unit, which can result in the unit overheating.

The risk

An overheated reverse gear control unit increases the risk of a fire.

The remedy

As an interim remedy, the reverse gear control unit will be disconnected from the electrical system of the motorcycle, free of charge. Dealers will replace the reverse gear control unit, free of charge. Owner notification letters were mailed on April 7, 2025 Owners may contact BMW Customer Service at 1-800-525-7417.

BMW of North America, LLC · up to 5,048 vehicles across all model years covered

The contact owns a 2022 BMW R 18. The contact received notification of NHTSA Campaign Number: 23V884000 (Exterior Lighting) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA complaint 11580654. Filed by an owner and not verified by NHTSA or by us.

I bought a 2022 BMW R18B motorcycle in 2023. There are 3 models of this motorcycle. R18 is plain without a fairing or smart controls. The R18 Transcontinental is top of line with fairing computer, navigation, phone pairing. The R18B which is my motorcycle is basically the same as Transcontinental except it does not have top case and rack for mounting top case. Here is the safety problem with the R18B. The Transcontinental has running and brake light built into top case. Directional signals are mounted on saddlebags. they also do braking. but on the R18B which has no top case there isn't a rear fender mounted running and brake light. Only a license plate light and small reflector. brake and …

NHTSA complaint 11578707, quoted in part. Filed by an owner and not verified by NHTSA or by us.

Adaptive headlight does not work and the low beam reflector is completely loose. With the reflector loose the headlight will occasionally blind oncoming traffic, point to the sky or side of the road. It is unsafe to ride unless riding with high beams, which is not safe for oncoming traffic.

NHTSA complaint 11548809. Filed by an owner and not verified by NHTSA or by us.

While on a multi-state trip I noticed that two pieces of the headlight have come loose inside the lens distorting the beam. On September 19, 2023 I took the bike in for a warranty claim and it was approved. Now two weeks later the dealer is still unable to give me a time frame for replacement due to the number of theses that have failed. I cannot ride the bike for fear of it going out entirely for safety as well as a law violation. I definitely cannot ride it at night for obvious reasons. The bike has 7000 miles now with most of a 3 year/36000 mile warranty remaining.

NHTSA complaint 11548286. Filed by an owner and not verified by NHTSA or by us.

The BMW R18 B motorcycle is equipped with an adaptive headlight, which directs the headlight beam in the direction of the motorcycle's lean angle and handlebar rotation; however, the headlight has failed, where the reflective mirror pieces have fallen apart. The loose reflective pieces creates a dazzling effect in the direction of the light beam; this appears to be a high failure item on the R18 B and Transcontinental models, equipped with the adaptive headlight. I dropped my motorcycle off for service in order to have the headlight failure repaired under warranty in May, where the BMW service center just notified me 4 months later that the headlight has arrived from Germany and is ready to …

NHTSA complaint 11541825, quoted in part. Filed by an owner and not verified by NHTSA or by us.