2017 Jaguar XE

The defect

Jaguar Land Rover North America, LLC (Jaguar) is recalling certain 2017-2018 and 2020 Jaguar XE vehicles that received a replacement rear rail assembly as part of a service repair. Missing spot welds may weaken the structural strength of the rear rail assembly.

The risk

The weakened rear rail assembly may allow the rear bumper beam to detach when the vehicle is being towed or the tow-bar assembly to detach when towing a trailer. Either of these scenarios can increase the risk of a crash.

The remedy

Jaguar will notify owners, and dealers will replace the rear rail assembly, free of charge. Owner letters were mailed May 7, 2021. Owners may contact Jaguar customer service at 1-800-452-4827. Jaguar's number for this recall is H349.

Jaguar Land Rover North America, LLC · up to 3 vehicles across all model years covered

The defect

Jaguar Land Rover North America, LLC (Jaguar) is recalling certain 2017 XE vehicles equipped with a 2.0L diesel engine. The vehicles have a fuel return hose that may leak.

The risk

A diesel fuel leak onto the road surface may cause a skid hazard, increasing the risk of a crash. If the fuel leak contacts a hot engine or exhaust component, there would be an increased risk of a fire.

The remedy

Jaguar will notify owners, and dealers will replace the fuel return hose, free of charge. The began May 2, 2017. Owners may contact Jaguar customer service at 1-800-452-4827. Jaguar's number for this recall is H016.

Jaguar Land Rover North America, LLC · up to 7 vehicles across all model years covered

Still open engineering analysis · opened September 17, 2021

the air bags

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

62,000 miles

The contact owns a 2017 Jaguar XE. The contact stated that while driving at an undisclosed speed, the air bag warning light illuminated. A dealer was contacted. The vehicle was taken to a dealer, where it was diagnosed and determined that the passenger’s side air bag had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and transferred the contact to the warranty headquarters located in Florida. The approximate failure mileage was 62,000.

NHTSA complaint 11713656. Filed by an owner and not verified by NHTSA or by us.

towed · 101,820 miles

The contact owns a 2017 Jaguar XE. The contact stated that while driving approximately 20 MPH, the check engine and battery warning lights illuminated, and the vehicle stalled. The vehicle could not able to be restarted. The vehicle was towed to the residence. The vehicle was then towed to an independent mechanic, where it was diagnosed, and determined that the fuel line needed to be replaced. The manufacturer was not notified of the failure. The failure mileage was 101,820.

NHTSA complaint 11676704. Filed by an owner and not verified by NHTSA or by us.

towed

The contact owns a 2017 Jaguar XE. The contact stated that while driving at an undisclosed speed, the contact noticed an abnormally strong fuel odor. The contact parked the vehicle. Upon inspecting the vehicle, the contact noticed that there was a large amount of diesel on the ground underneath the vehicle. The vehicle was towed to an independent mechanic, where it was diagnosed with a hole in the fuel return line. The contact was informed that the fuel return line needed to be replaced. The vehicle was repaired; however, the failure recurred the following day. The vehicle was not repaired. The contact related the failure to an unknown recall; however, the VIN was not included. No further …

NHTSA complaint 11662624, quoted in part. Filed by an owner and not verified by NHTSA or by us.

131,630 miles

The contact owns a 2017 Jaguar XE. The contact stated that while parked and attempting to start the vehicle, the contact heard abnormal sound coming from the engine and the vehicle failed to respond as needed. The contact stated that on another occasion while attempting to start the vehicle, the vehicle responded as needed. The vehicle was taken to an independent mechanic where it was diagnosed that the timing chain needed to be replaced. The vehicle was not repaired. The vehicle was repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 131,630.

NHTSA complaint 11649605. Filed by an owner and not verified by NHTSA or by us.

This vehicle has left me stranded with my family multiple times with out being able to pull over on the side of the road. It’s had so many coolant leaks, hoses bust, and a hand full of coolant leaks in the whole system. The jaguar dealership has worked on vehicle multiple of times without any success. The vehicle while driving didn’t even warn me the coolant was low. When I pulled over and opened the hood, it busted of the coolant cap on its own and coolant was busting out everywhere cause it to leak on me.

NHTSA complaint 11617073. Filed by an owner and not verified by NHTSA or by us.