2022 Ford Ecosport

The defect

Ford Motor Company (Ford) is recalling certain 2021-2022 EcoSport vehicles. The front axle half shafts may disconnect from the transmission, which can result in a loss of drive power.

The risk

A loss of drive power increases the risk of a crash. In addition, a disconnected half shaft can result in a vehicle rollaway if the parking brake is not applied, increasing the risk of a crash or injury.

The remedy

Dealers will inspect and replace the half shafts as necessary, free of charge. Owner notification letters were mailed on May 29, 2025. Owners may contact Ford customer service at 866-436-7332. Ford's number for this recall is 25S12.

Ford Motor Company · up to 18,648 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2016-2018 Ford Focus and 2018-2022 Ford EcoSport vehicles. The oil pump drive belt or drive belt tensioner may fail, resulting in a loss of engine oil pressure.

The risk

A loss of oil pressure can result in an engine stall and a loss of power braking assist, increasing the risk of a crash.

The remedy

Dealers will replace the oil pump tensioner assembly and oil pump drive belt, free of charge. If engine failure occurs due to a damaged oil pump belt and/or oil pump belt tensioner, Ford has authorized dealers to replace the engine assembly as an interim repair before the availability of remedy parts for the final repair. This repair will be free of charge (parts and labor). Owner notification letters were mailed August 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S64.

Ford Motor Company · up to 139,730 vehicles across all model years covered

crash · towed · 2,000 miles

The contact owns a 2022 Ford Ecosport. The contact stated that while at a stop, the brake pedal was depressed when the vehicle inadvertently lunged forward. Due to the failure, the vehicle crashed into the side of her daughter’s house. No warning lights were illuminated. The contact stated that the air bags failed to deploy. No injuries were sustained. No medical attention was required. A police report was not filed. The vehicle was towed to an independent mechanic but was not diagnosed. Neither the dealer nor the manufacturer was notified of the failure. The approximate failure mileage was 2,000.

NHTSA complaint 11487075. Filed by an owner and not verified by NHTSA or by us.

crash · towed

The vehicle (MAJ6S3KL1NC474743) was impacted on the passenger side and the air bags failed to deploy. the safety risk caused hospital visit and numerous doctor visits. The problem was confirmed by enterprise, PO Box 801770, Kansas City Mo. 64180 Damage Recovery Unit. (866) 300-3239. The following have infer inspection of the vehicle: enterprise, police and the insurance companies. There were no signs of warnings or malfunction or other symptoms prior to the impact from the on coming vehicle.

NHTSA complaint 11537347. Filed by an owner and not verified by NHTSA or by us.

My 2022 Ford EcoSport has approximately 27,000 miles. I began experiencing a repetitive rotational thudding noise coming from the front of the vehicle while driving. The noise occurs while the vehicle is moving. On September 1, 2026, I took the vehicle to NTB for inspection. NTB diagnosed the vehicle as needing both front wheel bearings and tie rods at approximately 27,000 miles. I am concerned about multiple steering/wheel components requiring replacement at such low mileage. Failure of a wheel bearing or tie rod could affect the driver's ability to safely control the vehicle if the components continue to deteriorate or fail while driving. The vehicle and affected components are available …

NHTSA complaint 11767173, quoted in part. Filed by an owner and not verified by NHTSA or by us.

The vehicle was built at the Chennai, India plant on April 22, 2022. Official NHTSA recall 25V126 (Ford 25S12) covers 2021‑2022 EcoSports built between April 1, 2021 and July 20, 2022—my build date falls inside that window. The vehicle exhibits the exact symptoms described in the recall: a jolt/clunk when shifting into reverse and a shudder from the transmission area during road driving. A Ford dealer technician documented “felt shudder from converter will need checked” during a road test. The dealer confirmed the build date and the symptoms but refused to inspect or repair the half‑shafts under the safety recall. They stated they “cannot perform a recall that does not apply to the …

NHTSA complaint 11725995, quoted in part. Filed by an owner and not verified by NHTSA or by us.

The left‑side roof rail trim detached from the vehicle while driving, creating a road hazard that could have struck another vehicle or pedestrian. The remaining right‑side trim is now lifting and is likely to detach as well. Ford has previously issued safety recalls (21S22, 24S02) for roof rail and pillar trim detachment on other models (e.g., Explorer) because loose trim can fly off and cause crashes. A Ford dealer was asked to address this safety concern under goodwill or warranty, but the request was ignored. The problem is visible and the vehicle is currently at the dealer. No warning lamps are associated. The detached trim is no longer available for inspection, but the remaining …

NHTSA complaint 11725996, quoted in part. Filed by an owner and not verified by NHTSA or by us.

I bought a 2022 Ford Ecosport. The seatbelts are not working and I am currently down to one seatbelt in the rear seats that work. I haul 3 children regularly and now am having to transport without a seatbelt which is against the law and totally unsafe. I called Ricart’s in Columbus Ohio and they want $100 per seatbelt to fix. At this point I am expecting the other seatbelts not to work soon. I called the Ford customer service number and was told that is not on the recall list and unfortunately they cannot assist me even though I am hauling small children. I t is a MAJOR SAFETY ISSUE being these are children and if I get into and accident we all know What will happen and I will take this …

NHTSA complaint 11714644, quoted in part. Filed by an owner and not verified by NHTSA or by us.

My License Plate Lights fall down in front of the license plate. I have had them fixed 5 times by the dealer during the time I have owned the car- which is almost 3 years. My warranty will be expiring 13 August 2025. I have been told by the dealership if this happens after my warranty is up, I will be responsible for the cost of repair plus labor. I do not feel this is fair. The lights falling out are not due to any neglect on my part. I contacted FORD & they suggested I contact you so that possibly this could be checked into for a safety recall. The dates of the repairs are: 21 Jan 2023 driver side 06 July 2023 both 29 Sep 2023 both 10 Aug 2024 both 10 July 2025 driver side

NHTSA complaint 11676221. Filed by an owner and not verified by NHTSA or by us.

34,835 miles

The contact owns a 2022 Ford EcoSport. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer where it was diagnosed and determine that the catalytic converter was cracked and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage is 34,835.

NHTSA complaint 11629664. Filed by an owner and not verified by NHTSA or by us.