2023 Lincoln Corsair

The defect

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2021-2023 Corsair, and 2022-2023 Maverick vehicles equipped with 2.5L HEV or PHEV engines that were repaired incorrectly under recall 23V380. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

The risk

An engine compartment fire increases the risk of injury.

The remedy

Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S54.

Ford Motor Company · up to 1,809 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2024-2025 Lincoln Nautilus, 2023-2025 Escape, 2023 Lincoln Corsair, 2025 Lincoln Corsair, Maverick, and Bronco Sport vehicles equipped with a 1.5L or 2.0L MPC engine and an engine block heater. The engine block heater may overheat when the vehicle is parked with the block heater plugged in.

The risk

An overheated engine block heater can increase the risk of a fire.

The remedy

Dealers will replace the block heater element and inspect the electrical cord, replacing it if necessary, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug coupled, and remove the block heater electrical cord. Owner notification letters were mailed June 9, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S52.

Ford Motor Company · up to 6,781 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2020-2023 Lincoln Aviator and Lincoln Corsair vehicles equipped with a Revel Audio System that were repaired incorrectly under recall 22V-953. When the driver's seat belt is not buckled and the vehicle is started, the seat belt warning system may activate the audible warning chime for an insufficient amount of time of less than 4 seconds. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

The risk

An audible warning chime that does not properly alert of an unbelted seat belt can increase the risk of injury during a crash.

The remedy

Dealers will update the audio control module software, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C18.

Ford Motor Company · up to 4,442 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.

The risk

A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.

The remedy

The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.

Ford Motor Company · up to 1,076,138 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2020-2024 Ford Escape, and 2021-2024 Lincoln Corsair vehicles. A manufacturing defect in one or more of the high voltage battery cells may result in an internal short circuit and battery failure.

The risk

Battery failure can cause a loss of drive power, increasing the risk of a crash. Battery failure can also increase the risk of a fire.

The remedy

Owners are advised not to charge battery till the remedy has been completed. Dealers will perform a battery energy control module (BECM) software update, and replace the high voltage battery pack, as necessary, free of charge. Owner notification letters were mailed on May 30, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S79.

Ford Motor Company · up to 20,484 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."

The risk

Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.

The remedy

Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.

Ford Motor Company · up to 27,678 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.

The risk

A fuel leak in the presence of an ignition source increases the risk of a fire.

The remedy

Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.

Ford Motor Company · up to 24 vehicles across all model years covered

The defect

Ford Motor Company (Ford) is recalling certain 2020-2023 Escape, 2022-2023 Maverick, and 2021-2023 Corsair vehicles equipped with 2.5L HEV or PHEV engines. In the event of an engine failure, engine oil and fuel vapor may be released into the engine compartment and accumulate near ignition sources such as hot engine or exhaust components, possibly resulting in an engine compartment fire.

The risk

An engine compartment fire increases the risk of injury.

The remedy

Owners are advised to park and shut off the engine as quickly as possible if they hear unexpected engine noises, notice a reduction in vehicle power, or see smoke. Dealers will replace the engine long-block in 2023 Escape and Corsair vehicles. For the other vehicles, dealers will update the powertrain control module software. If a connecting rod bearing failure is detected, dealers will replace the engine long-block. All inspections and repairs will be performed free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S27. This recall expands and replaces recall number 22V-484. Vehicles previously repaired under 22V-484 will need to have the new remedy completed.

Ford Motor Company · up to 125,322 vehicles across all model years covered

The contact owns a 2023 Lincoln Corsair. The contact received notification of NHTSA Campaign Number: 26V091000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.

NHTSA complaint 11752196. Filed by an owner and not verified by NHTSA or by us.

On May 10 a lighted wrench appeared on the instrument panel. The car felt as if I was loosing power. May 12 I got in the car, the wrench and check engine lights were both on. Called the dealer service department. They told me the car is not safe to drive as it cannot accelerator and will go into "limp mode". After having it towed to the Lincoln dealership, I was told the turbo in the engine failed. As of July 6, there is not a part available for this repair. Today I was told there are only 3 in the entire nation and they are all accounted for.

NHTSA complaint 11748517. Filed by an owner and not verified by NHTSA or by us.

The contact owns a (YMM) 2010 Hyundai Elantra. The contact received notification of NHTSA Campaign Number: (example: 20V315000 (Latches/Locks/Linkages) however, the part to do the recall repair was not yet available. The local dealer was/was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was/was not made aware of the issue. The contact had not experienced a failure. The VIN was invalid./The VIN was not available.

NHTSA complaint 11740657. Filed by an owner and not verified by NHTSA or by us.

The recall letter advised that for the time being, I should set software to limit charge to 80%. The car is noncompliant with the prescribed settings. If there is a danger to having settings no prescribed, I am in danger. I did set the settings in the car and in the Android app to 80%. Sometimes the 80% limit is respected, but often it charges to 100%. Even though the Android app always reports the setting as 80%. the car sometimes doesn't comply. I only charge in my garage, in the same spot, using a Level 2 charger. The recall letter also advised that the drive mode should be set to "Auto EV." But the Corsair does not have a setting called "Auto EV." I called several numbers at Ford, and …

NHTSA complaint 11730944, quoted in part. Filed by an owner and not verified by NHTSA or by us.

I was getting back into the car, shut the door (at a normal level) and heard a loud bang coming from above me then heard the glass falling onto the cover. Got out and realized it was a spontaneous rupture of the sun roof.

NHTSA complaint 11725334. Filed by an owner and not verified by NHTSA or by us.

While driving, the moonroof spontaneously shattered. There was no impact whatsoever. Just shattered. Glass was everywhere.

NHTSA complaint 11707909. Filed by an owner and not verified by NHTSA or by us.