CSR
Check a VIN

Look up

About

Ford · NHTSA safety record

2011 Ford Flex

Every safety complaint, recall and defect investigation the US government holds on this vehicle.

144

Complaints

5

Crashes

1

Fires

9

Injuries

1

Deaths

Owners of the 2011 Ford Flex have filed 144 safety complaints with NHTSA between October 2010 and May 2026. The most complained-about system is the steering, named in 57 of them (40%). The typical failure was reported at 73,500 miles, the median across the 117 complaints that gave an odometer reading.

NHTSA has issued 2 recalls covering this vehicle.

Recalls (2)

AIR BAGS:FRONTAL

16V247000 · April 26, 2016

The defect
Ford Motor Company (Ford) is recalling certain model year 2009-2012 Ford Flex, 2008 and 2010-2012 Ford Taurus, 2008-2009 Ford Taurus X, 2008 Mercury Sable, 2009 and 2011 Lincoln MKS vehicles. The driver frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
The risk
An improperly inflated air bag increases the risk of injury in the event of a crash.
The remedy
Ford will notify owners, and dealers will inspect and replace the driver's frontal air bag module, as necessary, free of charge. The recall is expected to begin on June 13, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C06.

Ford Motor Company · up to 695 vehicles across all model years covered

STEERING:ELECTRIC POWER ASSIST SYSTEM

15V340000 · June 2, 2015

The defect
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
The risk
If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
The remedy
Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.

Ford Motor Company · up to 393,623 vehicles across all model years covered

What owners report

Complaints naming each system. One complaint can name several, so these add up to more than 144.

STEERING 57 40%
ENGINE 25 17%
POWER TRAIN 19 13%
UNKNOWN OR OTHER 11 8%
ELECTRICAL SYSTEM 9 6%
SERVICE BRAKES 8 6%
ENGINE AND ENGINE COOLING 7 5%
SEATS 7 5%
FUEL/PROPULSION SYSTEM 5 3%
WHEELS 5 3%
STRUCTURE 4 3%
TIRES 3 2%

When the complaints arrived

By the year NHTSA received them, which is not the year the failures happened. They peaked in 2015 at 18.

2010 2015 2026
2010 to 2026, the last of them a part year

In owners' own words

Quoted from NHTSA's complaint file. These are unverified accounts by the people who filed them, not findings of fault.

AIR BAGS

1 death · 1 injured · fire · crash · towed

This accident didn’t involve myself. It involved my father who borrowed my 2011 Ford Flex for the evening. This was a one vehicle accident. It is unknown what happened to cause him to Swerve and hit a hit. The air bags didn’t deploy in the Vehicle. My father was wearing his seatbelt. An electric fire started and the car burnt along with my father he wasn’t able to be pulled from the vehicle before it caught fire. According to the witnesses, the airbags did not go off. My father had blunt trauma to the chest and to his frontal lobe and broken ribs. In addition to lots of other injuries that would’ve been avoided if the airbags would have went off. My father could’ve been alive if the airbags

NHTSA complaint 11603939, quoted in part. Filed by an owner and not verified by NHTSA or by us.

FUEL/PROPULSION SYSTEM

2 injured · 89,300 miles

UPON ACCELERATION, USUALLY FROM A COMPLETE STOP SUCH AS ACCELERATING FROM A STOP SIGN OR ON A GREEN LIGHT, IT FEELS AS THOUGH THE GEARS DO NO CATCH & THE CAR JERKS AND THE RPM'S RAISE BUT THE CAR STOPS ACCELERATING. WILL ALSO HAVE A "STUTTERING" OR "JERKING" WHILE AT A COMPLETE STOP WITH BREAK PEDAL BEING PRESSED DOWN. I HAVE TAKEN THIS ISSUE TO THE DEALERSHIP AS IT IS STILL UNDER EXTENDED WARRANTY AND HAVE BEEN TOLD THAT EVERYTHING CHECKED OUT NORMAL & THE MECHANIC AT THE DEALERSHIP WAS UNABLE TO GET THE VEHICLE TO HAVE SUCH DESCRIBED MALFUNCTIONS BECAUSE IT IS DOESN'T HAPPEN EVERY SINGLE TIME THE CAR IS DRIVEN. THE JERKING WHILE DRIVING ACTUALLY OCCURS ON A DAILY BASIS BUT IS SPORADIC &

NHTSA complaint 10734655, quoted in part. Filed by an owner and not verified by NHTSA or by us.

AIR BAGS

1 injured · crash · towed · 105,000 miles

ON 2100 HRS 21 NOV 2015, MY DAUGHTER WAS INVOLVED IN A DEER STRIKE ACCIDENT ON HWY 36 VICINITY HAMILTON, MISSOURI. SHE WAS TRAVELING EAST ON THE HIGHWAY 36 AT 55-60 MPH WHEN A DEER RAN INTO THE PATH OF THE CAR. THE IMPACT WAS FROM CENTER LINE OF THE CAR TOWARDS THE DRIVERS SIDE. SHE APPLIED THE BRAKES UPON SEEING THE DEER BUT THE STRIKE AND APPLICATION OF BRAKES WERE PRETTY MUCH SIMULTANEOUS. SHE PULLED THE CAR OFF THE ROAD AND COULDN'T EXIT THE DRIVER'S DOOR BECAUSE THE FRONT FENDER OVERLAPPING THE DOOR DUE TO IMPACT. THE AIRBAG DID NOT DEPLOY, SHE WAS WEARING HER SEAT BELT WHICH PROBABLY SAVED HER FROM ANY MAJOR INJURIES. BASED UPON THE FRONTAL DAMAGE TO THE VEHICLE THE AIRBAG SHOULD HAVE

NHTSA complaint 10806256, quoted in part. Filed by an owner and not verified by NHTSA or by us.

UNKNOWN OR OTHER

1 injured · crash · towed · 64,000 miles

WE WERE DRIVING AROUND 25MPH AND SUDDENLY EVERYTHING WAS UNRESPONSIVE. WHEEL COULDN'T BE CONTROLLED AND BRAKES HAD NO EFFECT. WE SPUN OUT OF CONTROL UNTIL 2 PARKED CARS STOPPED US.

NHTSA complaint 10896775. Filed by an owner and not verified by NHTSA or by us.

STEERING
I have had this vehicle since about August 2025, the brakes and wheel bearings have failed twice, the strut failed, the power steering system has messed up repeatedly, the coolant came FLYING out of the car (while parked) FOR ABSOLUTELY NO REASON! There have been multiple warning lights on since I got the vehicle and I have been told they are just sensors from multiple mechanics and that they don't mean anything. As it relates to the issues, the brakes, calipers, and wheel bearings have given out twice WHILE DRIVING without any sort of warning up until they seized! The strut on the front passenger side has broken for no known reason and the power steering system has been non stop eating

NHTSA complaint 11736911, quoted in part. Filed by an owner and not verified by NHTSA or by us.

POWER TRAIN
Went to put car in reverse and it kept driving forward- no weird sound or anything. Proceeded to put the car in park and it was still moving forward. Transmission was stuck on drive.The shifter is disconnected from the transmission with no warning .Just looked and the transmission shifter bushing is disconnected. Also saw that this part is a recall on other ford vehicles. Had this been recalled on all vehicles with this part, I would have known to have it fixed. Luckily I was somewhere safe when this happened but it would have put myself as well as others in danger.

NHTSA complaint 11734241. Filed by an owner and not verified by NHTSA or by us.

EXTERIOR LIGHTING
I had changed all my bulbs and fuses to my car for my brake lights several times and they still don’t work. My car almost got hit with me and my kids in it due to my break lights not working. Also my car keeps saying service advance trac and keeps saying it every time I drive. My car also keeps running out of power steering fluid every two week I have to add more to keep it from making that loud noise while driving.

NHTSA complaint 11694945. Filed by an owner and not verified by NHTSA or by us.

SERVICE BRAKES
My brakes locked up suddenly on the rear end causing me to get stuck in the middle of the road and unable to move it, even to tow it. I had to take 2 days almost to fix it in the middle of the road, since yesterday morning. They also began locking up suddenly on the front end, the wheel bearing, CV Joint, Tie Rods, CV Axles, CV Boots, and sway bars began failing out of nowhere as well. The brakes may or may not be able to be replicated, as they are partially fixed and yes my entire front end can be replicated. The danger is my brakes locked up as I was driving, in the middle of the road at that. I have not been able to get the front end fixed as it is expensive, however the danger of this

NHTSA complaint 11694344, quoted in part. Filed by an owner and not verified by NHTSA or by us.

STEERING

170,000 miles

The contact owns a 2011 Ford Flex. The contact stated that on several occasions while attempting to start the vehicle, the power steering assist warning light illuminated, and the steering wheel became firm. The vehicle was taken to a dealer where it was diagnosed that the electronic power steering module link needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The contact believed that the failure was associated with NHTSA Campaign Number: 15V340000 (Steering). The manufacturer was notified of the failure. The failure mileage was approximately 170,000.

NHTSA complaint 11681381. Filed by an owner and not verified by NHTSA or by us.

STEERING
Electric Power Steering lights up and steering wheel locks up, can hardly make it move at it. We turn the car off and turn it back on. Sometimes the power steering returns, sometimes it doesn't and we can't drive the car. We called the dealer after this happened and they said it was an ECOBOOST Flex and wasn't included in the Safety Recall 15S18 National Highway Traffic Safety Administration (.gov) Jul 1, 2015 — If any "loss of steering assist" DTCs are present, replace the power steering gear assembly. It seems that this is the exact problem as noted in the recall but Ford dealership will not fix it for free. Ford gave me a PDF that explains they are not responsible for this safety issue

NHTSA complaint 11659824, quoted in part. Filed by an owner and not verified by NHTSA or by us.

Compare

Other years of the Ford Flex

Model year Complaints Recalls Deaths
2019 235 4 —
2018 61 3 —
2017 42 4 —
2016 95 3 —
2015 103 4 —
2014 249 4 —
2013 578 6 —
2012 64 2 —
2010 139 1 —

Other 2011 Ford models

Fusion 2,783 F-150 2,184 Edge 1,801 Escape 1,314 Explorer 1,195 Fiesta 729 Mustang 466 F-250 248

Every Ford on this site — 348 vehicles, 1210 recall campaigns and 10 open investigation s.

If this is your car and a dealer keeps failing to fix it, your state's lemon law may require the manufacturer to replace it or buy it back. What each state asks for , read from the statutes.

Where these numbers come from

A complaint is one owner's account and has not been verified by NHTSA or by us. A vehicle with more complaints is not necessarily worse: models that sold in larger numbers collect more of them. How this is counted.

Compiled and maintained by
Independent developer and analyst