CSR
Check a VIN

Look up

About

Ford · NHTSA safety record

2013 Ford Flex

Every safety complaint, recall and defect investigation the US government holds on this vehicle.

578

Complaints

11

Crashes

1

Fires

13

Injuries

0

Deaths

Owners of the 2013 Ford Flex have filed 578 safety complaints with NHTSA between September 2012 and May 2026. The most complained-about system is the electrical system, named in 200 of them (35%). The typical failure was reported at 65,000 miles, the median across the 435 complaints that gave an odometer reading.

Complaints rose 26% year on year: 24 in the twelve months to 2026-Q1, against 19 in the twelve before.

NHTSA has issued 6 recalls covering this vehicle.

Recalls (6)

SUSPENSION:REAR

20V072000 · February 10, 2020

The defect
Ford Motor Company (Ford) is recalling certain 2013-2018 Lincoln MKT and Ford Flex and Taurus vehicles with the Police Interceptor or SHO Performance Pack. The rear suspension toe links may fracture due to stress on the rear suspension.
The risk
A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
The remedy
Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. Remedy parts are not currently available. Owners were notified about the recall on March 3, 2020. A second notice will be mailed when remedy parts become available, which is currently expected to be the end of September 2020. The recall began October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332 or Lincoln customer service at 1-800-521-4140. Ford's number for this recall is 20S04.

Ford Motor Company · up to 211,207 vehicles across all model years covered

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

16V621000 · August 25, 2016

The defect
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump.
The risk
A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash.
The remedy
Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31.

Ford Motor Company · up to 77,502 vehicles across all model years covered

FUEL SYSTEM, GASOLINE

15V812000 · December 2, 2015

The defect
Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.
The risk
A fuel leak in the presence of an ignition source may result in a fire.
The remedy
Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.

Ford Motor Company · up to 868 vehicles across all model years covered

STEERING:ELECTRIC POWER ASSIST SYSTEM

15V340000 · June 2, 2015

The defect
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
The risk
If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
The remedy
Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.

Ford Motor Company · up to 393,623 vehicles across all model years covered

POWER TRAIN:AXLE ASSEMBLY:AXLE SHAFT

14V393000 · July 2, 2014

The defect
Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
The risk
If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
The remedy
Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.

Ford Motor Company · up to 83,250 vehicles across all model years covered

FUEL SYSTEM, GASOLINE

13V227000 · May 31, 2013

The defect
Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.
The risk
A fuel leak in the presence of an ignition source may result in a fire.
The remedy
Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.

Ford Motor Company · up to 390,783 vehicles across all model years covered

What owners report

Complaints naming each system. One complaint can name several, so these add up to more than 578.

ELECTRICAL SYSTEM 200 35%
STEERING 149 26%
UNKNOWN OR OTHER 78 13%
STRUCTURE 69 12%
FUEL/PROPULSION SYSTEM 59 10%
EXTERIOR LIGHTING 36 6%
ENGINE 32 6%
ELECTRONIC STABILITY CONTROL (ESC) 24 4%
LATCHES/LOCKS/LINKAGES 21 4%
SUSPENSION 17 3%
FUEL SYSTEM, GASOLINE 12 2%
SEAT BELTS 12 2%

When the complaints arrived

By the year NHTSA received them, which is not the year the failures happened. They peaked in 2016 at 100.

2012 2016 2026
2012 to 2026, the last of them a part year

In owners' own words

Quoted from NHTSA's complaint file. These are unverified accounts by the people who filed them, not findings of fault.

FUEL/PROPULSION SYSTEM

4 injured · 24,000 miles

A 2013 FORD FLEX RENTAL VEHICLE USED FOR A 4-HOUR DRIVE FROM THE SAN DIEGO AREA TO SOUTHERN ARIZONA WAS LEAKING GASOLINE FUMES, WHICH KEPT ENTERING THE CABIN AND MADE ALL PASSENGERS NAUSEOUS, INCLUDING AN ELDERLY FEMALE WITH ALZHEIMER'S DISEASE. THE VEHICLE WAS PARKED INSIDE A GARAGE OVERNIGHT AND THE FOLLOWING MORNING ALL THE INTERIOR AREAS OF THE HOUSE, INCLUDING ALL BEDROOMS, WERE SATURATED WITH A VERY POTENT SMELL OF GASOLINE. AFTER INSPECTING THE HOUSE, IT BECAME OBVIOUS THAT THE FUMES WERE COMING FROM THE RENTAL 2013 FORD FLEX VEHICLE, AND THE GARAGE HAD AN EXTREMELY POTENT CONCENTRATION OF GASOLINE FUMES. ALTHOUGH THERE WAS NO EXPLOSION, WE ALL FELT ILL AND TOOK US ABOUT A WEEK TO

NHTSA complaint 10533510, quoted in part. Filed by an owner and not verified by NHTSA or by us.

POWER TRAIN

2 injured · crash · towed

Steering locked up lower control arm snapped at the ball joint where it's connected to cv axel. Sent my car into the rails and nearly.killed me and my passenger.

NHTSA complaint 11594309. Filed by an owner and not verified by NHTSA or by us.

AIR BAGS

1 injured · crash · towed · 131,000 miles

THERE IS A RECALL ON THE ELECTRONIC POWER STEERING FOR CERTAIN 2013 FORD FLEX'S. RECALL 15S18. THE MANUFACTURER SAYS THAT MINE DOES NOT QUALIFY FOR THE BUT THE VEHICLE HAS THE SAME SYMPTOMS AS THE RECALL CAMPAIGN. THE POWER STEERING WAS OUT ON MY VEHICLE, IT LOCKED UP AROUND A CURVE WHEN I WAS DOING ABOUT 50 MILES AN HOUR. THE VEHICLE WOULD NOT TURN RIGHT, I CROSSED A LANE OF ONCOMING TRAFFIC AND HIT A TREE ON SUNDAY 11 18 18. I WAS ON HIGHWAY 70 IN KINGSTON TENNESSEE, HEADED EASTBOUND. THE STEERING WHEEL IS VERY LOOSE AND IN A BIND AS IF THE STEERING WHEEL WAS LOCKED WITH KEYS OUT OF THE IGNITION. I HIT THE TREE DOING ABOUT 35 MPH TO 40 MPH WHEN STEERING BECAME INOP AND THE AIRBAGS DID NOT

NHTSA complaint 11152846, quoted in part. Filed by an owner and not verified by NHTSA or by us.

AIR BAGS

1 injured · crash · towed · 169,725 miles

WE HAVE 2 COMPLAINTS ABOUT THE AIRBAGS. I WAS DRIVING 65MPH ON HIGHWAY AND HIT A BEAR ON FRONT DRIVERS SIDE (AIRBAG DID NOT DEPLOY.) REPAIRED THE CAR. MY DAUGHTER WAS IN A HIGHWAY COLLISION REAR ENDED A PERSON AT 43 -45 MPH AIRBAGS DID NOT DEPLOY. INFORMED YESTERDAY THE CAR IS A TOTAL LOSS. SHE HAD HER GLASSES THROWN OFF HER FACE DASH WAS PUSHED BACK, TROOPER AND TOW TRUCK DRIVER WERE SHOCKED THEY DIDN'T GO OFF. SHE WAS NOT INJURED HAVING CONCUSSIVE SYMPTOMS. WE ALSO FOUND OUT THAT THE VIN DOES NOT MATCH THE INTERIOR OF THE CAR AS THEY WERE RUNNING THE SPECS OF THE VEHICLE. THE VIN IS SAYING THAT IT IS A CLOTH INTERIOR AND MY CAR HAS LEATHER INTERIOR. IF IT WAS AN UPGRADE IT SHOULD STILL BE

NHTSA complaint 11406063, quoted in part. Filed by an owner and not verified by NHTSA or by us.

ELECTRICAL SYSTEM
What component or system failed or malfunctioned, and is it available for inspection upon request? MULTIPLE DRIVER AID FUNCATIONS IN-OP. DRIVER DOOR LOCKS WILL NOT LOCK OR UNLOCK, DRIVER DOOR LOCK AND UNLOCK SWITCH WILL NOT OPERATE ANY LOCKS, PASSENGER DOOR MIRROR WILL NOT MOVE, SEAT MEMORY WILL NOT SAVE, REAR VIEW MIRROR WILL NOT AUTO DIM AND THERE IS NO MANUAL OPTION TO ADJUST THE MIRROR RESULTING IN IMPACTED NIGHT VISABLITY, REAR VIEW CAMERA DOES NOT DISPLAY ON SCREEN BUT WILL BEEP WHEN CLOSE TO AN OBJECT. NOT CODES OR DASH WARNINGS DISPLAYED TO STORED. How was your safety or the safety of others put at risk? IMPACTED VISIBLY WHILE DRIVING. UNABLE TO ADUST PASSENGER MIRROR TO SEE BLINK

NHTSA complaint 11736539, quoted in part. Filed by an owner and not verified by NHTSA or by us.

ENGINE
What component or system failed or malfunctioned, and is it available for inspection upon request? INTERNAL WATER PUMP/ TIMING CHAINS/ VVT SOLENOIDS/ CAM PHASERS/ CAM SENSORS/ RELATED SEALS How was your safety or the safety of others put at risk? ENGINE FAILURE - SUDDEN STOP OF VEHICLE Has the problem been reproduced or confirmed by a dealer or independent service center? YES, IS AWARE AND HAS ACKNOWLEDGED VIA SERVICE AND TECH BULLETINS THAT THIS IS A KNOWN AND REPEATED ISSUE. ISSUE IS KNOWN AND COMMON WITH ALL 3.7L AND 3.5L FORD ENGINES. MANUFACTURER HAS HAD PETTY AND CLASS ACTION SUITS RELATED TO THIS FAILURE AND IS NOT TAKING ANY ACTION TO REMEDY ASIDE FROM A "EXTENDED WARRANTY" FOR

NHTSA complaint 11736541, quoted in part. Filed by an owner and not verified by NHTSA or by us.

STEERING

140,000 miles

The contact owns a 2013 Ford Flex. The contact stated that while driving at an undisclosed speed, the steering wheel seized, with the power steering fault warning light illuminated. The vehicle was restarted; however, the failure reoccurred, and the steering wheel became difficult to turn. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the steering rack and steering angle and torque sensors had failed and needed to be replaced. The vehicle was not repaired. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, and several cases were filed. The failure mileage was approximately

NHTSA complaint 11732762, quoted in part. Filed by an owner and not verified by NHTSA or by us.

SUSPENSION

127,000 miles

The contact owns a 2013 Ford Flex. The vehicle was taken to a dealer for a recall repair. The contact stated the dealer declined to perform the recall repair because the vehicle was unable to be started. The contact received notification of NHTSA Campaign Number: 20V072000 (SUSPENSION). The vehicle was currently at the dealer. The vehicle was not repaired. The manufacturer was not made aware of the issue. The failure mileage was 127,000.

NHTSA complaint 11721838. Filed by an owner and not verified by NHTSA or by us.

SEATS

1 injured

On Sunday, February 22, 2026, I was driving my 2013 Ford Flex with the driver’s seat heater activated. After a period of use, I began to notice an unusual electrical burning smell inside the vehicle. There were no dashboard warning lights or system alerts. I turned the seat heater off immediately once I detected the smell. I did not initially notice an injury at that time. The following day, I experienced significant pain and discovered burns on my buttocks in the area consistent with seat contact. I sought medical evaluation three days later and was diagnosed with second- to third-degree burns. Prescription treatment was provided. The vehicle has not yet been inspected for the cause of the

NHTSA complaint 11720492, quoted in part. Filed by an owner and not verified by NHTSA or by us.

VISIBILITY/WIPER
Rear view camera has failed. The screen goes black and has a “contact dealer” message.

NHTSA complaint 11716037. Filed by an owner and not verified by NHTSA or by us.

Compare

Other years of the Ford Flex

Model year Complaints Recalls Deaths
2019 235 4 —
2018 61 3 —
2017 42 4 —
2016 95 3 —
2015 103 4 —
2014 249 4 —
2012 64 2 —
2011 144 2 1
2010 139 1 —

Other 2013 Ford models

F-150 2,972 Escape 2,744 Edge 2,439 Explorer 2,229 Focus 2,105 Fusion 1,784 Fiesta 667 Taurus 581

Every Ford on this site — 348 vehicles, 1210 recall campaigns and 10 open investigation s.

If this is your car and a dealer keeps failing to fix it, your state's lemon law may require the manufacturer to replace it or buy it back. What each state asks for , read from the statutes.

Where these numbers come from

A complaint is one owner's account and has not been verified by NHTSA or by us. A vehicle with more complaints is not necessarily worse: models that sold in larger numbers collect more of them. How this is counted.

Compiled and maintained by
Independent developer and analyst