2012 Toyota RAV4

The defect

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2012 RAV4 vehicles manufactured July 28, 2005, to December 19, 2012, and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the event of a frontal collision, the rear seat belts for the outboard seats may be cut by the seat cushion frame.

The risk

A cut seat belt may not properly restrain the seat occupant, increasing their risk of injury in a crash.

The remedy

Toyota will notify owners, and dealers will install a protector over both rear seat cushion frames, free of charge. The recall began on June 24, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0F.

Toyota Motor Engineering & Manufacturing · up to 1,123,752 vehicles across all model years covered

The defect

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2009-2012 RAV4 vehicles manufactured October 27, 2008, to December 19, 2012 and 2012-2014 RAV4 EV vehicles manufactured July 24, 2012, to August 29, 2014. In the affected vehicles, water may drip onto the joint that connects the wiper linkage to the wiper motor.

The risk

Over time, the dripping water may cause corrosion and wear at the joint, potentially resulting in the separation of the wiper linkage. Once this occurs, the wipers would not function, reducing driver visibility and increasing the risk of a crash.

The remedy

Toyota will notify owners, and dealers will replace the water diverter channel. In addition, a new wiper linkage with a wiper motor crank arm will be installed. The wiper linkage will have a protective cover over the wiper linkage joint to minimize water splash and a retainer ring to prevent the wiper arm from separating from the wiper motor. The recall began on November 7, 2016. Owners may contact Toyota's customer service number at 1-800-331-4331.

Toyota Motor Engineering & Manufacturing · up to 423,456 vehicles across all model years covered

The defect

Toyota is recalling certain model year 2012 and 2013 Toyota Tacoma and Lexus RX350 vehicles and certain model year 2012 Toyota Rav4 vehicles. In the affected vehicles, the brake system contains a brake actuator that adjusts the fluid pressure of each wheel cylinder. An electrical component within the actuator may experience an increased resistance resulting in the illumination of various warning lights, including those for the Vehicle Stability Control (VSC) system, Antilock Brake System (ABS), and Traction Control system.

The risk

If this occurs, these systems could become inoperative, reducing the directional control assistance, increasing the risk of a crash.

The remedy

Toyota will notify owners, and Toyota and Lexus dealers will update the software for the Skid Control electronic control unit, free of charge. The recall began on March 28, 2014. Owners may contact Toyota at 1-800-331-4331.

Toyota Motor Engineering & Manufacturing · up to 261,114 vehicles across all model years covered

The defect

Southeast Toyota is recalling certain model year 2008 and 2010-2013 Toyota Tundra, 2010-2012 Rav4, 2012 Toyota Sequoia, 2010-2011 Toyota Corolla, 2010-2011 Toyota Camry and Camry Hybrid, 2010-2013 Toyota Highlander and Highlander Hybrid, 2010-2013 Toyota FJ Cruiser, 2011 Toyota Land Cruiser, 2010-2013 Toyota Venza, 2010-2011 Toyota 4Runner, 2010-2013 Toyota Tacoma, 2011-2012 Toyota Sienna, 2012 Toyota Prius, 2013 Scion FR-S, 2011 Scion XD, 2011 Scion XB, and 2012 Scion TC vehicles. These vehicles were sold with labels that were outside the allowable one percent of accuracy of actual weight added. Thus, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) Number 110, "Tire Selection and Rims."

The risk

An inaccurate label could lead to owners overloading their vehicles and tires. An overloaded vehicle can result in a tire failure which may result in a vehicle crash, personal injury, or property damage.

The remedy

Southeast Toyota will notify owners and provide a corrected label with instructions concerning its installation. A small group of the affected vehicles will need additonal remedies which are still being developed. The recall began on May 28, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Southeast Toyota Distributors, LLC · up to 7,525 vehicles across all model years covered

The defect

Southeast Toyota Distributors, LLC (SET) is recalling certain models interspersed through model years 2009 through 2013 as follows: model year 2009-2012 Tacoma, 4Runner, Camry, Camry Hybrid, Prius, and RAV4; model year 2009-2010 Avalon, FJ Cruiser, and Highlander Hybrid; model year 2010-2013 model year Corolla, Sienna and Tundra; model year 2009-2013 Highlander and Venza; model year 2012 Prius V; and model year 2010-2012 Sequoia. During modification by SET to include accessories such as leather seat covers, seat heaters or headrest DVD systems, these vehicles may not have had the passenger seat occupant sensing system calibration tested. Without passing the calibration test, the occupant sensing system may not operate as designed.

The risk

If the front passenger seat occupant sensing system is out of calibration, the front passenger airbags may not deploy or they may deploy inappropriately for the passenger's size and position. This could increase the risk of personal injury during the event of a vehicle crash necessitating airbag deployment.

The remedy

Southeast Toyota will notify owners, and dealers will test the sensitivity of the occupant detection sensors, and recalibrate them as necessary. The recall began on March 21, 2013. Owners may contact Southeast Toyota at 1-800-301-6859.

Southeast Toyota Distributors, LLC · up to 3,235 vehicles across all model years covered

My 2012 Toyota RAV4 (Super White / Blizzard Pearl paint) is experiencing severe and recurring paint peeling caused by a known manufacturing defect in which the factory paint primer failed to properly adhere to the base metal layer. The peeling first began in 2023 following freezing weather in Austin, TX. It occurred again in 2024 after another freeze event, and then once more in 2025, at which point a large section of roof paint peeled off completely, exposing bare metal. I attempted to repair the damage with spray paint but the new paint continues to peel off as well, because the underlying adhesion defect was never corrected. This confirms the failure is rooted in the original factory …

NHTSA complaint 11744656, quoted in part. Filed by an owner and not verified by NHTSA or by us.

My vehicle is a 2012 rav 4 sport, color Barcelona Red. Said color and model has been know to have clear coat and paint issues. My vehicles clear coat and paint in the top has been peeling at an alarming rate, a year or so ago it started, but the last 6 months have been excrutiating. This problem poses a risk to me as if the issue continues on, oxidation might occur and possibly lead to holes in the surface. To other paint flying off from the vehicle might distract them in the porcess of driving and the glare produces by it might impact others vision. Other areas that have been affected include, hood and side mirrors.

NHTSA complaint 11735644. Filed by an owner and not verified by NHTSA or by us.

138,000 miles

The contact owns a 2012 Toyota Rav4. The contact stated that while driving at various speeds, the vehicle shuddered abnormally. The contact stated that the vehicle was consuming an excessive amount of engine oil. Several unknown warning lights were illuminated. The vehicle was taken to a local Auto Zone, where it was scanned with an OBD2 scanner and DTC: P0607, P1603, and P1604 were retrieved. The vehicle was taken to another local independent mechanic, where it was diagnosed with an unknown electrical failure. The vehicle was not repaired due to the cost. The local dealer was not contacted. The vehicle was not repaired. In addition, the contact related the failure to an unknown recall; …

NHTSA complaint 11715035, quoted in part. Filed by an owner and not verified by NHTSA or by us.

The small pipe that's part of the Upper Radiator Coolant Hose Connector Adapter broke off and drained coolant from the vehicle. This small pipe had deteriorated and become brittle leading to the failure.

NHTSA complaint 11702129. Filed by an owner and not verified by NHTSA or by us.

The windshield pump is not working front and back The wipers turn but no liquid comes out though the tank is full It does not make the sound it normally does when it pumps the windshield liquid Dealer wants almost $200 just to look at it and verify the problem

NHTSA complaint 11687761. Filed by an owner and not verified by NHTSA or by us.

I have a 2012 Toyota Rav-4 Limited . I have had the vehicle since 2020. Ever since I bought the vehicle it fogs up. All the windows fog up and it does not matter what setting I have it on, de-foggers, fan, fresh air, AC, etc. nothing resolves the problem.It is very dangerous as I cannot see where I am going. I cannot use the front de-foggers in bad weather because it makes the afore mentioned problem worse.I have to put the windows down to see and this remedy is not feasible. I have researched and a lot of other people are experiencing this same safety issue in this model vehicle. I love the vehicle but dread bad weather as it is a struggle to see . Please help.

NHTSA complaint 11675227. Filed by an owner and not verified by NHTSA or by us.