2015 Mazda MAZDA6

The defect

Mazda North American Operations (Mazda) is recalling certain 2014-2015 Mazda6 and 2014-2016 Mazda3 vehicles. Water could possibly enter the brake caliper causing the parking brake actuator shaft to corrode and possibly bind.

The risk

If the parking brake actuator shaft binds, the parking brake may not engage or disengage fully. If the parking brake does not engage properly, the vehicle may move unexpectedly if it is parked on a slope, increasing the risk of a crash.

The remedy

Mazda will notify owners, and dealers will check the parking brake actuator shafts, replacing any that are corroded, free of charge. Remedy parts are currently unavailable. Interim notices informing owners of the safety risk were mailed August 24, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Mazda customer service at 1-800-222-5500. Mazda's number for this recall is 1217F.

Mazda North American Operations · up to 227,814 vehicles across all model years covered

The defect

Mazda North American Operations (Mazda) is recalling certain model year 2014-2015 Mazda6 vehicles manufactured October 25, 2012, to October 10, 2014. If the pressures of four of the tires on an affected vehicle gradually drop at the same time, the tire pressure monitoring system (TPMS) may not warn the driver of the drop in pressure. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard (FMVSS) No. 138, "Tire Pressure Monitoring System."

The risk

A vehicle that is driven with under inflated tires may experience a sudden tire failure, increasing the risk of a crash.

The remedy

Mazda will notify owners, and dealers will update the TPMS software, free of charge. The recall began on December 10, 2014. Owners may contact Mazda customer service at 1-800-222-5500.

Mazda North American Operations · up to 99,711 vehicles across all model years covered

The defect

Mazda North America Operations (Mazda) is recalling certain model year 2014 Mazda3 vehicles manufactured June 12, 2013, through December 18, 2013, and model year 2014-2015 Mazda6 vehicles manufactured May 20, 2013, through December 4, 2013, and both equipped with a 2.5L engine and a regenerative engine braking system. When driving the affected vehicles in heavy rain or in deep puddles, the alternator belt may slip causing the Power Control module (PCM) to incorrectly assume failure of the charging system.

The risk

Once the PCM assumes that the charging system has failed, the vehicle will stop charging and could result in poor acceleration, loss of steering assist and windshield wiper operation, and a possible engine stall, increasing the risk of a crash.

The remedy

Mazda will notify owners, and dealers will reprogram the PCM with updated software, free of charge. The recall began on May 19, 2014. Owners may contact Mazda at 1-800-222-5500. Mazda's number for this recall is 7314D.

Mazda North American Operations · up to 5,700 vehicles across all model years covered

crash · towed · 32,000 miles

THIS CAR HAS HAD MANY RANDOM COMPUTER PROBLEMS STARTING WITH TRANSMISSION LOCKING IN LOW GEAR UNTIL YOU STOP THE CAR AND RESTART. CAR SHUTS OFF DISPLAYING AUTOMATIC STOP BREAK GOT VERY HARD AND STEERING VERY HARD. MY DAUGHTER HAD AN ACCIDENT LAST WEEK 2/2/17 DUE TO VEHICLE LOSS OF POWER HARD BREAKING AND STEERING. CALLED MAZDA WITH NO RESPONSE.

NHTSA complaint 10955354. Filed by an owner and not verified by NHTSA or by us.

crash · 3,900 miles

MY WIFE MOVED OUR 2015 MAZDA6. SHE MOVED THE CAR DOWN THE DRIVEWAY, PRESSED THE BRAKE TO BRING THE CAR TO A COMPLETE STOP AND SHIFTED THE CAR INTO PARK. SHE THEN PROCEEDED TO PRESS THE BUTTON TO TURN OFF THE VEHICLE. IN DOING SO, THE ENGINE TURNED OFF AND WHEN SHE RELEASED THE BRAKE THE CAR ROLLED 3 FEET. FRANTICALLY, SHE PUSHED DOWN ON THE BRAKE AND PULLED UP THE EMERGENCY BRAKE. HOWEVER, THE CAR ROLLED INTO A POST AT THE END OF THE DRIVEWAY CAUSING DAMAGE TO THE HOOD, MOLDING AND BOTTOM BUMPER OF OUR BRAND NEW VEHICLE. *TR

NHTSA complaint 10678280. Filed by an owner and not verified by NHTSA or by us.

111,000 miles

The contact owns a 2015 Mazda Mazda6. The contact stated that while driving at an undisclosed speed, there was a loud clanking sound coming from the rear end on the passenger's side. The contact stated that while the vehicle was parked, the contact noticed that the rear end of the vehicle was severely corroded. The contact reached out to a mobile independent mechanic, and it was determined that the underbody of the vehicle was severely damaged and could not be repaired or replaced. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 111,000.

NHTSA complaint 11658432. Filed by an owner and not verified by NHTSA or by us.

towed · 100,000 miles

The contact owns a 2015 Mazda Mazda6. The contact stated while driving at an undisclosed speed, there was an abnormally loud clicking sound coming from the vehicle. The contact stated that the rear of the vehicle was bouncing, and the clicking sound was extremely loud. The contact stopped and parked the vehicle. The contact was fearful of driving the vehicle. The vehicle was towed to the residence. The contact stated that an independent mobile mechanic visited the residence and inspected the vehicle. The vehicle was diagnosed with severe corrosion of the suspension. The contact was informed that the corrosion was irreparable. In addition, the contact was informed that the rear passenger’s …

NHTSA complaint 11656508, quoted in part. Filed by an owner and not verified by NHTSA or by us.

Fuel started leaking after 90,000 miles when tank is over 3/4 full.

NHTSA complaint 11641324. Filed by an owner and not verified by NHTSA or by us.

90,000 miles

The contact owns a 2015 Mazda Mazda6. The contact stated that after refueling, the odor of fuel was present inside and outside the vehicle. The contact stated that there was fuel leaking underneath the rear driver's side of the vehicle. The contact stated that the failure occurred whenever there was more than 3/4 tank full of fuel in the fuel tank. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 90,000.

NHTSA complaint 11630400. Filed by an owner and not verified by NHTSA or by us.

See attached document for complaint.

NHTSA complaint 11616869. Filed by an owner and not verified by NHTSA or by us.

crash

Hi, car was involved in a small fender bender. Airbags were NOT deployed. However, an error code 19 (B0001) came on the dash related to driver side sensor. If not fixed, airbags will not deploy in case of accident and that puts me and my family in danger. Dealer won't service the vehicle because it has more than 100,000 miles (122,000 miles to be exact on my car). Other mechanics won't touch the airbag system. What am I supposed to do as the car is not safe to be driven and dealer refusing to help.

NHTSA complaint 11611049. Filed by an owner and not verified by NHTSA or by us.