2018 Volkswagen Passat

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Golf R and Atlas, 2017 Golf Alltrack and E-Golf and 2016-2018 Passat vehicles. These internal use vehicles were sold without confirmation that they were built to all applicable regulatory requirements and may have been modified prior to sale. As such, these vehicles may fail to comply with the requirements of various Federal Motor Vehicle Safety Standards.

The risk

Vehicles that do not meet all regulatory requirements may have an increased risk of a crash or injury to vehicle occupants.

The remedy

Volkswagen will notify owners and will repurchase the vehicles. The recall began October 6, 2020. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 01E9.

Volkswagen Group of America, Inc. · up to 23 vehicles across all model years covered

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2012-2020 Volkswagen Passat and 2018-2019 Atlas vehicles. The blocking cap disabling the adjustment of the headlight's horizontal aim may not have been installed. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

The risk

Without the blocking cap, the headlight aim can be adjusted out of specification, reducing visibility and increasing the risk of a crash.

The remedy

Volkswagen will notify owners, and dealers will inspect and, as necessary, block the headlight horizontal adjustment, free of charge. The recall began July 16, 2019. Owners may contact Volkswagen customer service at 1-800-253-2834. Volkswagen's number for this recall is 94L9.

Volkswagen Group of America, Inc. · up to 662,185 vehicles across all model years covered

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2018 Volkswagen Atlas and 2017-2018 Volkswagen Passat vehicles. The brake caliper bracket mounting bolts on these vehicles may not have been tightened sufficiently.

The risk

The loose brake bracket bolts can allow the caliper to move, reducing braking ability or causing a loss of vehicle control and increasing the risk of a crash.

The remedy

Volkswagen will notify owners, and dealers will inspect the brake caliper bracket bolt tightness, replacing and re-torque the bolts as necessary, free of charge. Additionally brake caliper fasteners, bleeder valve, and brake hose bolts will be checked and torqued to the correct specification, if necessary, free of charge. For Passat vehicles, dealers will also inspect the parking brake cable for proper connection, free of charge. The recall began September 14, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 46H6.

Volkswagen Group of America, Inc. · up to 8,416 vehicles across all model years covered

crash · towed

I was driving down the road and the wheel locked up and I lost control of the car. I thought it was just a flat tire. I noticed the tire was flat and brake caliber was lying on the inside of the rim. There was extensive damage to the vehicle, tire, rim, suspension components and brake components. There was no warning and it just happened suddenly. My family and other drivers safety were at risk. The dealership said it was due to impact but their estimate didn't mention or included any of the brake components. The brake caliber bracket is broken and the holes were the caliber bolts attached are elongated. The brake caliber and bracket are protected inside the rim and brakes just don't fall …

NHTSA complaint 11445457, quoted in part. Filed by an owner and not verified by NHTSA or by us.

crash · towed

Collision around 45 to 50 mph. Airbags frontal and side airbags didnt deployed Two vehicles invaded my lane and I ran into the second vehicle .

NHTSA complaint 11563910. Filed by an owner and not verified by NHTSA or by us.

crash

The vehicle can be turned off while in drive, and gives no extra signals (beeps, flashing lights, etc.) with the exception of a brief message on the dash and single ding (same ding for door open, and other low importance messages). The vehicle will then roll until the brake is applied or it comes to a rest on a flat surface or against a pole or hard object. This is a significant safety hazard that has occurred to me 3-4 times, the most recent was today when the vehicle rolled backwards down my mothers driveway. Crossed the street, entered the neighbors driveway/yard, contacted the mail box and came to rest in the front yard. The vehicle rolled approx. 200ft. The vehicle is equipped with …

NHTSA complaint 11428647, quoted in part. Filed by an owner and not verified by NHTSA or by us.

A major engineering and material design failure occurred involving internal fluid containment seals, resulting in a severe electrical safety hazard. Pressurized engine coolant breached an internal component seal and began migrating internally directly through the vehicle's engine wiring harness via capillary/siphoning action. The fluid used the sealed wiring loom as a literal pipeline, traveling inside the wire insulation to bypass all outer weather seals and completely flood the Engine Control Module (ECM) pin connectors. The vehicle's dealership service department documented extensive galvanic corrosion and shorting inside the primary vehicle computer pins due to this blue-green fluid …

NHTSA complaint 11741923, quoted in part. Filed by an owner and not verified by NHTSA or by us.

70,000 miles

The contact owns a 2018 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, the infotainment screen failed to respond to touch commands, preventing the contact from viewing the GPS feature. The contact performed a hard reset on the vehicle, but the failure persisted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 70,000.

NHTSA complaint 11731417. Filed by an owner and not verified by NHTSA or by us.

towed · 136,000 miles

The contact owns a 2018 Volkswagen Passat. The contact stated that while driving at an undisclosed speed, the vehicle stalled. There was no warning light illuminated. The vehicle was unable to restart and was towed to the dealer to be diagnosed. The vehicle was diagnosed with battery failure. The contact was informed that the battery needed to be replaced. The vehicle was repaired; however, the failure recurred. The vehicle was then towed to a different dealer; however, the vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 136,000.

NHTSA complaint 11715843. Filed by an owner and not verified by NHTSA or by us.

I initially brought my vehicle in for service due to a strong gasoline odor and the vehicle failing to start. At that time, I was informed that no gasoline smell was detected and that the issue was instead a faulty starter, which I authorized for repair. Approximately two weeks later, my vehicle again would not start. I was then informed that the issue was a lower fuel injector, which required additional repairs. Just three days after that service, the vehicle once again failed to start, and I was told this time that the upper fuel injector was the cause. As a result of these events, I incurred a total of $3,946.96 in repair costs across two service visits and was forced to have my vehicle …

NHTSA complaint 11715421, quoted in part. Filed by an owner and not verified by NHTSA or by us.

55,000 miles

The contact owns a 2018 Volkswagen Passat. The contact stated that while driving approximately 40 MPH, the vehicle made an abnormal sound and failed to accelerate as intended. There was no warning light illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed with a wiring harness failure. The vehicle was repaired. The contact had received an unknown notice, which was related to the failure. The manufacturer was contacted for reimbursement, and a case was filed. The contact sent the requested documents to the manufacturer; however, the manufacturer failed to call back as the manufacturer had stated. The failure mileage was approximately 55,000.

NHTSA complaint 11714408. Filed by an owner and not verified by NHTSA or by us.

Battery drains overnight. Started with a boost all dashboard warning lights on, vehicle runs fine all day with many starts and stops, battery dies again overnight. Diagnosed with a bad fuel pump control module that continues to run and does not shut off until all battery power is drained. Mechanic changed the fuel pump control module, cleared all fault codes, and vehicle fixed. I saw a Carfax report for an identical 2018, SEL Premium Passat to mine with the exact same issue of a bad fuel control module in that vehicle Carfax report and realized it was a much bigger issue. I am aware of a similar recall for vehicles up till 2016 model year, but this issue is wider for higher model years. …

NHTSA complaint 11711803, quoted in part. Filed by an owner and not verified by NHTSA or by us.