2020 Toyota Supra

The defect

BMW of North America, LLC (BMW) is recalling certain 2020 M340i, M340i xDrive, 540i, 540i xDrive, X3 M40i, 2020-2021 X4 M40i, 745Le xDrive, 2019-2021 Z4 M40i, and 2020-2021 Toyota Supra vehicles. During engine start, the engine management software may cause loss of braking assist. Full mechanical braking (without assist) remains available.

The risk

Loss of braking assist can increase the risk of a crash.

The remedy

Dealers will update the engine management software, free of charge. Owner notification letters were mailed on September 17, 2021. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 50,024 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020-2021 Z4 and 2020-2021 Toyota Supra vehicles. The weld between the fuel tank halves may have been insufficiently welded, causing the weld to fail.

The risk

The failed weld may allow fuel to leak, increasing the risk of a fire in the presence of an ignition source.

The remedy

BMW will notify owners, and dealers will replace the fuel tank, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.

BMW of North America, LLC · up to 49 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2019-2020 Z4 sDrive30i, Z4 M40i and 2020 Toyota Supra vehicles. The headlamps are able to be adjusted horizontally. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices and Associated Equipment."

The risk

Should the headlamps be adjusted horizontally, there could be increased glare and reduced visibility for oncoming drivers, or reduced visibility for the vehicle operator, thereby increasing the risk of a crash.

The remedy

BMW will notify owners, and dealers will inspect the headlamp vertical and horizontal adjustment plugs, correcting them as necessary, free of charge. The recall began December 23, 2020. BMW owners may contact BMW customer service at 1-800-525-7417 or Toyota owners may contact Toyota customer service at 1-888-270-9371.

BMW of North America, LLC · up to 4,265 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2019 Z4 sDrive30i, 2019-2020 330i xDrive, M340i and M340i xDrive, 2020 X3M and X4M, and Toyota Supra vehicles. In certain driving conditions, such as high temperatures and rough road surfaces, a steering gear tie rod may become damaged, possibly resulting in a fractured tie rod.

The risk

A damaged or fractured tie rod may affect vehicle handling and control, increasing the risk of a crash.

The remedy

BMW and Toyota will notify owners, and dealers will replace the steering gear tie rods, free of charge. The recall began August 14, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.

BMW of North America, LLC · up to 2,779 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020 Z4 M40i, Z4 sDrive30i, 330i and 330i xDrive vehicles as well as 2020 Toyota Supra vehicles. The headlight control units may fail causing a loss of one or both of the headlights.

The risk

Headlight failure can reduce the driver's visibility, increasing the risk of a crash.

The remedy

BMW will notify owners, and dealers will replace the headlight control units, free of charge. The recall is expected to begin January 17, 2020. Owners may contact BMW customer service at 1-800-525-7417 or Toyota customer service at 1-888-270-9371.

BMW of North America, LLC · up to 245 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

The risk

The lack of an image in the back-up camera display increases the risk of a crash.

The remedy

BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.

BMW of North America, LLC · up to 257,473 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020 Toyota Supra vehicles. The driver's seat belt guide loop mount may have been improperly welded.

The risk

In the event of a crash, the mount could become damaged and the seat belt may not properly restrain the driver, increasing their risk of injury.

The remedy

Owners have been notified, and Toyota dealers will inspect the seat belt guide loop mount. If the mount is defective, the vehicle will be replaced, free of charge. The recall began October 16, 2019. Owners may contact the Toyota Customer Experience Center at 1-888-270-9371. Toyota's number for this recall is K0R.

BMW of North America, LLC · up to 7 vehicles across all model years covered

crash · towed · 1,495 miles

I WAS STOPPED IN THE LEFT TURN LANE AT A RED LIGHT. THE TURN ARROW SWITCHED TO GREEN SO I TOOK THE U-TURN. I WAS IN THE MIDDLE OF THE U-TURN GOING ABOUT 15 MPH, WHEN THE CAR BEGAN TO ACCELERATE ON ITS OWN. THE CAR OVERSTEERED, AND THE REAR PORTION OF THE CAR KICKED OUT TO THE RIGHT SIDE. I CORRECTED BY COUNTERSTEERING AND REMOVING MY FOOT FROM THE ACCELERATOR PEDAL. THE CAR CONTINUED TO ACCELERATE, CAUSING ME TO OVERSTEER TO THE LEFT SIDE THIS TIME. IN AN EFFORT TO STOP THE CAR, I SLAMMED ON THE BRAKES WHILE OVERSTEERING. THIS CAUSED THE CAR TO ROTATE COUNTER CLOCKWISE, AND IMPACTED WITH THE CURB AND ENDED UP ON TOP OF THE MEDIAN. THERE WAS SIGNIFICANT DAMAGE TO THE REAR PASSENGER …

NHTSA complaint 11329047, quoted in part. Filed by an owner and not verified by NHTSA or by us.

crash

rear end crash

NHTSA complaint 11694444. Filed by an owner and not verified by NHTSA or by us.

towed · 197 miles

TL* THE CONTACT OWNS A 2020 TOYOTA SUPRA. WHILE DRIVING 60 MPH, THE STEERING WHEEL BEGAN TO VIBRATE AND BECAME DIFFICULT TO TURN. WHEN TURNING THE STEERING WHEEL, THE WHEELS FAILED TO MOVE AND THE POWER STEERING MALFUNCTION WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE STEERING WHEEL SEIZED IN A PARKING LOT. THE VEHICLE WAS NOT ABLE TO BE DRIVEN. THE VEHICLE WAS TOWED TO GERMAIN TOYOTA OF NAPLES (LOCATED AT 13315 TAMIAMI TRAIL N, NAPLES, FL 34110, (239) 301-3313) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 197.

NHTSA complaint 11253613. Filed by an owner and not verified by NHTSA or by us.

There is currently an ongoing recall for the GR Supra over the starter. I currently drive a 2020 and have had periodic starter malfunctions. This is when I go to start the car it states starter system malfunction then lets me still turn it on after clearing the error message. I have brought this up to my dealership and due to the intermittent nature of the issue they said they could not diagnose and that continuity was good so they would not replace it and if they did it would not be covered. I fear that my car is a fire risk based on the recall notices for all the other model years and that when it happens I will be left holding the bag. The date listed below (7/17/2026) is just the last …

NHTSA complaint 11752727, quoted in part. Filed by an owner and not verified by NHTSA or by us.

I am reporting a safety concern involving BMW and Toyota vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found in 2019–2021 models. These engines use a variable displacement oil pump with an internal thermoplastic adjusting component that regulates oil pressure. Field reports show this component can fracture, causing sudden loss or instability of oil pressure—most often during cold starts in low temperatures. When the part fails, oil pressure regulation becomes erratic or disappears entirely, often with little or no useful warning before engine damage or vehicle disablement. Reported early signs include failed electronic oil level readings, abnormal pressure …

NHTSA complaint 11725612, quoted in part. Filed by an owner and not verified by NHTSA or by us.

towed · 25,000 miles

The contact owns a 2020 Toyota Supra. The contact stated that while attempting to start the vehicle with the Push-to-Start button, the vehicle hesitated while starting. A message that the engine was overheating was displayed. The contact stated that the vehicle was idling in Low Power Mode while at a stoplight, and the vehicle hesitated while accelerating with the accelerator pedal depressed. The vehicle then suddenly jolted forward. The failure was temporarily fixed after shifting to SPORT Mode. The vehicle was towed to a local dealer, where the starter was replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was towed to a local independent BMW Service Center, …

NHTSA complaint 11722286, quoted in part. Filed by an owner and not verified by NHTSA or by us.

I am reporting a safety concern involving BMW and Toyota Supra vehicles equipped with the B58 Technical Update (B58TU) engine, commonly found in model years 2019–2021. These vehicles utilize a variable-displacement engine oil pump containing an internal thermoplastic adjusting component responsible for regulating oil pressure. Field failures are increasingly being reported in which this internal component fractures, resulting in sudden loss or instability of engine oil pressure. The failure frequently occurs during cold-start operation in low ambient temperatures. When the component fails, oil pressure regulation becomes erratic or is lost entirely. In many cases, drivers receive little or …

NHTSA complaint 11721032, quoted in part. Filed by an owner and not verified by NHTSA or by us.

The 2020 - 2025 Toyota Supra is manufactured by BMW and uses virtually all components supplied by BMW. The vehicle includes dual climate controls (driver / passenger) and the temperature of the air from the vents is controlled independently. It is known by BMW that the blend door or the actuator (motor) - which regulates how much cold versus hot air is mixed per the control setting - can break or be deformed. This is a manufacturing defect in the heating unit, not a wear issue. No heat is available to the driver either through the center vent, the left vent, and most importantly from a safety standpoint, the vents at the windshield. This means defrosting or defogging the windshield during …

NHTSA complaint 11639790, quoted in part. Filed by an owner and not verified by NHTSA or by us.