CSR
Check a VIN

Look up

About

Kia · NHTSA safety record

2016 Kia RIO

Every safety complaint, recall and defect investigation the US government holds on this vehicle.

77

Complaints

7

Crashes

5

Fires

5

Injuries

0

Deaths

Owners of the 2016 Kia RIO have filed 77 safety complaints with NHTSA between October 2016 and June 2026. The most complained-about system is the engine, named in 38 of them (49%). The typical failure was reported at 50,500 miles, the median across the 22 complaints that gave an odometer reading.

NHTSA has issued 2 recalls covering this vehicle. A further 1 defect investigation is open and unresolved.

Recalls (2)

SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP:CONTROL UNIT/MODULE

23V652000 · September 25, 2023

Park outside until repaired

The defect
Kia America, Inc. (Kia) is recalling certain 2010-2019 Borrego, 2014-2016 Cadenza, 2010-2013 Forte, Forte Koup, Sportage, 2015-2018 K900, 2011-2015 Optima, 2011-2013 Optima Hybrid, Soul, 2012-2017 Rio, 2011-2014 Sorento, and 2010-2011 Rondo vehicles. The Hydraulic Electronic Control Unit (HECU) may experience an electrical short, which can result in an engine compartment fire while parked or driving.
The risk
An engine compartment fire while parked or driving can increase the risk of injury.
The remedy
Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will replace the HECU fuse, free of charge. Interim notification letters, notifying owners of the safety risk, were mailed November 14, 2023. Owner notification letters were mailed March 29, 2024 through June 18, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC284.

Kia America, Inc. · up to 1,730,192 vehicles across all model years covered

LATCHES/LOCKS/LINKAGES:TRUNK LID:LATCH

23V594000 · August 24, 2023

The defect
Kia America, Inc. (Kia) is recalling certain 2016-2017 Rio, 2016-2018 Optima, 2017-2018 Optima Hybrid and Optima Plug-in Hybrid vehicles. The trunk latch base may crack, preventing the opening of the trunk from the inside. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 401, "Internal Trunk Release."
The risk
A person inside the trunk compartment may become trapped, increasing their risk of injury.
The remedy
Dealers will replace the trunk latch base subassembly, free of charge. Owner notification letters were mailed October 19, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC278.

Kia America, Inc. · up to 319,436 vehicles across all model years covered

Defect investigations (1)

An investigation means NHTSA has decided a pattern is worth examining. A preliminary evaluation is often closed with no action; an engineering analysis is the stage that usually precedes a recall.

Hyundai and Kia ABS Module Fires

AQ23002

Still open audit query · opened November 17, 2023

the hydraulic brakes

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

What owners report

Complaints naming each system. One complaint can name several, so these add up to more than 77.

ENGINE 38 49%
UNKNOWN OR OTHER 15 19%
SERVICE BRAKES, HYDRAULIC 12 16%
ELECTRICAL SYSTEM 8 10%
POWER TRAIN 5 6%
SERVICE BRAKES 5 6%
AIR BAGS 4 5%
EXTERIOR LIGHTING 4 5%
FUEL/PROPULSION SYSTEM 4 5%
ENGINE AND ENGINE COOLING 3 4%
STEERING 3 4%
STRUCTURE 2 3%

When the complaints arrived

By the year NHTSA received them, which is not the year the failures happened. They peaked in 2024 at 23.

2016 2024 2026
2016 to 2026, the last of them a part year

In owners' own words

Quoted from NHTSA's complaint file. These are unverified accounts by the people who filed them, not findings of fault.

AIR BAGS

2 injured · crash · towed

The air bags malfunction they didn’t go off and seatbelt didn’t lock on impact. Yes my safety was at risk. I keep calling them and they not do pick up the phone I get transferred back to the receptionist. The insurance company is doing their inspection the police as well. No warnings.

NHTSA complaint 11420741. Filed by an owner and not verified by NHTSA or by us.

ENGINE

1 injured · fire

On May 29th 2021 my 2016 Kia Rio engine caught on fire after multiple attempts of letting Kia know that my engine had a possible recall/detect. I was told that my car wasn’t apart of the recall list of considered on the list of the 1.6 million or billion others who’s engines have blown up as well. I have paper work/trail of recent mechanical work/mechanics informing me with “possible recall issues as well”. Paid for an oil change May 21st, visited the mechanic and 8 days later my car was in flames at an EXXON gas station pump, literally traumatized.

NHTSA complaint 11421680. Filed by an owner and not verified by NHTSA or by us.

AIR BAGS

1 injured · crash · towed

ON NOVEMBER 18, 2018 AT APPROXIMATELY 6:30PM, I WAS INVOLVED IN A CAR ACCIDENT WHERE I REAR ENDED A CAR IN FRONT OF ME WHILE MOVING AROUND 30 MPH IN THE MERGING RAMP OF HWY 57 TO HWY 210 NEAR SAN DIMAS, CA AND I FILED A POLICE REPORT. THE AIRBAG DID NOT INFLATE/DEPLOY.

NHTSA complaint 11154895. Filed by an owner and not verified by NHTSA or by us.

AIR BAGS

1 injured · crash · 51,000 miles

ON SEPTEMBER 16, 2016 AT APPROXIMATELY9:12PM, I [XXX] , HAD JUST PICKED UP A PASSENGER WAS INVOLVED IN A CAR ACCIDENT . WHERE AS I WAS REAR ENDED WHILE AT A COMPLETE STOP AT A SIGNAL LIGHT AT THE INTERSECTION OF SOUTHWESTERN AND MOCKINGBIRD WITH THE PASSENGER IN THE CAR. THERE WAS A POLICE REPORT FILED THE NUMBER IS [XXX] THE AIRBAG DID NOT DEPLORE .....UPDATED 10/26/16 *BF INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA complaint 10914893. Filed by an owner and not verified by NHTSA or by us.

EXTERIOR LIGHTING
I am filing this complaint regarding a persistent low beam headlight failure on my 2016 Kia Rio that has not been resolved after a paid repair at an authorized Kia dealership. The low beam headlights on my vehicle stopped functioning. I brought the vehicle to Car Pros Kia in [XXX] for diagnosis and repair on XXX.. The dealership diagnosed the issue as a faulty Body Control Module (BCM) and replaced it on XXX. The dealership released the car to me with a 25-point inspection reading that all exterior lights were functional. The repair did not fix the problem — my low beams remain non-functional. I returned the vehicle on May 15th, 2026 so they can remedy the repair. They released my vehicle

NHTSA complaint 11742052, quoted in part. Filed by an owner and not verified by NHTSA or by us.

EXTERIOR LIGHTING
I am filing a complaint regarding repeated failures of the LED tail light assemblies on my 2016 Kia Rio. This vehicle uses combination tail lights that include both standard bulbs and integrated LED brake lights. The LED portion has failed multiple times over the life of the vehicle. I am now experiencing failure again, requiring replacement of multiple tail light assemblies. Each assembly costs approximately $400, and my vehicle requires four total units. This results in a significant repair cost for what should be a long-lasting component. LED lighting is widely expected to last far longer than traditional bulbs, and repeated failure raises concerns about product reliability and safety.

NHTSA complaint 11735244, quoted in part. Filed by an owner and not verified by NHTSA or by us.

ENGINE
My car is experiencing excessive oil consumption. Upon inspection, it was determined that the issue lies with my catalytic converter. I have discovered that this problem has been reported in other Kia vehicles. The information I found suggests that the oil I am using is being bypassed by the catalytic converter, which indicates a potential issue with the Kia car’s design. Engine light won’t go off

NHTSA complaint 11700990. Filed by an owner and not verified by NHTSA or by us.

ENGINE AND ENGINE COOLING

50,000 miles

The contact owns a 2016 Kia Rio. The contact stated that while inspecting the vehicle, it was discovered that there was no oil on the dipstick. The vehicle was taken to the local dealer, who was unable to determine the cause of the failure. An oil consumption test was performed; however, the failure persisted. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 50,000.

NHTSA complaint 11690274. Filed by an owner and not verified by NHTSA or by us.

ENGINE AND ENGINE COOLING

126,000 miles

The contact owns a 2016 Kia Rio. The contact stated that upon driving from a complete stop, the vehicle failed to exceed 2-3 MPH. There was no warning light illuminated. The contact was able to drive to the residence. The Ford dealer where the vehicle was purchased arranged for the vehicle to be picked up at the residence. The Ford dealer informed the contact that the mechanic and the Kia dealer where the vehicle was taken could not determine the cause of the failure. The contact then took the vehicle to an independent mechanic, where it was determined that the catalytic converter was clogged and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the

NHTSA complaint 11689368, quoted in part. Filed by an owner and not verified by NHTSA or by us.

ELECTRICAL SYSTEM

fire

I was driving when my Kia stalled and shut off but was still playing music and driving. So I pulled over and then my Kia caught on fire and went up in flames.

NHTSA complaint 11669451. Filed by an owner and not verified by NHTSA or by us.

Compare

Other years of the Kia RIO

Model year Complaints Recalls Deaths
2022 10 1 —
2021 15 2 —
2020 26 1 3
2019 21 1 —
2018 28 1 —
2017 31 2 —
2015 52 1 —
2014 52 1 —
2013 153 1 —
2012 54 1 —

Other 2016 Kia models

Sorento 1,242 Soul 798 Optima 751 Sedona 291 Forte 133 Sportage 130 Cadenza 14 K900 10

Every Kia on this site — 176 vehicles, 208 recall campaigns and 1 open investigation .

If this is your car and a dealer keeps failing to fix it, your state's lemon law may require the manufacturer to replace it or buy it back. What each state asks for , read from the statutes.

Where these numbers come from

A complaint is one owner's account and has not been verified by NHTSA or by us. A vehicle with more complaints is not necessarily worse: models that sold in larger numbers collect more of them. How this is counted.

Compiled and maintained by
Independent developer and analyst