CSR
Check a VIN

Look up

About

BMW · NHTSA safety record

2020 BMW 530I

Every safety complaint, recall and defect investigation the US government holds on this vehicle.

9

Complaints

3

Crashes

1

Fires

4

Injuries

0

Deaths

Owners of the 2020 BMW 530I have filed 9 safety complaints with NHTSA between January 2022 and April 2026. The most complained-about system is the electrical system, named in 3 of them (33%). The typical failure was reported at 700 miles, the median across the 1 complaints that gave an odometer reading.

NHTSA has issued 5 recalls covering this vehicle.

Recalls (5)

ELECTRICAL SYSTEM:STARTER ASSEMBLY:RELAY

25V636000 · September 23, 2025

Park outside until repaired

The defect
BMW of North America, LLC (BMW) is recalling certain 2019-2021 BMW 330i, 2019-2022 BMW Z4, 2020-2022 BMW 530i, X3, X4, Toyota Supra, 2021-2022 BMW 430i, 430i Convertible, and 2022 BMW 230i vehicles. The engine starter relay may corrode, causing the relay to overheat and short circuit.
The risk
A short circuit in the starter relay may increase the risk of a fire.
The remedy
Owners are advised to park their vehicles outside and away from structures until the remedy is complete. Dealers will replace the engine starter, free of charge. Owner notification letters were mailed February 6, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 14, 2025.

BMW of North America, LLC · up to 199,674 vehicles across all model years covered

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

21V096000 · February 19, 2021

The defect
BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
The risk
If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.
The remedy
BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 13,858 vehicles across all model years covered

POWER TRAIN:DRIVELINE:DRIVESHAFT

21V046000 · February 3, 2021

The defect
BMW of North America, LLC (BMW) is recalling certain 2020-2021 530i xDrive, 540i xDrive and 2021 740Li xDrive vehicles. The output shafts (left/right) which transfer power from the driveshaft to the rear wheels may break due to a heat treatment error during supplier production.
The risk
A broken output shaft can lead to a loss of drive power or a rollaway condition in a parked vehicle (if the parking brake is not engaged), increasing the risk of a crash.
The remedy
BMW will notify owners, and dealers will replace the output shaft(s), free of charge. The recall began March 24, 2021. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 28 vehicles across all model years covered

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

20V598000 · September 30, 2020

The defect
BMW of North America, LLC (BMW) is recalling certain 2020-2021 X3 sDrive 30i, X3 xDrive 30i, X3M 40i, X3 xDrive 30e, X4 xDrive 30i, X4M 40i, 530i, 540i, 540i xDrive, M550i xDrive, M5, 550e, 550e xDrive, and 550e iPerformance vehicles. A small portion of the rearview image may be slightly obscured. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
The risk
If the driver relies on only the rearview camera image, the reduced rearview image view can increase the risk of a crash or injury.
The remedy
BMW will notify owners, and dealers will inspect and, if necessary, program the rearview camera with updated software. The recall began November 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 312 vehicles across all model years covered

BACK OVER PREVENTION: SENSING SYSTEM: CAMERA

19V684000 · September 27, 2019

The defect
BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."
The risk
The lack of an image in the back-up camera display increases the risk of a crash.
The remedy
BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.

BMW of North America, LLC · up to 257,473 vehicles across all model years covered

What owners report

Complaints naming each system. One complaint can name several, so these add up to more than 9.

ELECTRICAL SYSTEM 3 33%
AIR BAGS 2 22%
ENGINE 2 22%
SERVICE BRAKES 2 22%
UNKNOWN OR OTHER 2 22%
EXTERIOR LIGHTING 1 11%
FUEL/PROPULSION SYSTEM 1 11%
STEERING 1 11%
SUSPENSION 1 11%

When the complaints arrived

By the year NHTSA received them, which is not the year the failures happened. They peaked in 2023 at 3.

2022 2023 2026
2022 to 2026, the last of them a part year

In owners' own words

Quoted from NHTSA's complaint file. These are unverified accounts by the people who filed them, not findings of fault.

SERVICE BRAKES

2 injured · crash · towed · 700 miles

The contact owns a 2020 BMW 530I. The contact stated that while driving at 20 MPH, the contact depressed on the brake pedal desperately, but the vehicle would not stop, causing the contact to rear-end the vehicle in front. There were front end damages to the contact's vehicle and rear end damages to the other vehicle. No warning light illuminated. The contact sustained head injuries that required medical attention. The driver in the other vehicle suffered injuries to the shoulders and the neck that required medical attention. A police report was filed. The vehicle was towed to the dealer. The vehicle was diagnosed by the dealer who stated no failure was found but the failure reoccurred. The

NHTSA complaint 11537215, quoted in part. Filed by an owner and not verified by NHTSA or by us.

ELECTRICAL SYSTEM

1 injured · crash · towed

The vehicle had a repair made by dealership. The repair started to malfunction as it would lock the vehicles driving mechanism making the vehicle non opporstional while driving. Issue was reported to the same dealer and explained. The dealer stated that I would receive a call to schedule a mechanical appointment to investigate however the time spent waiting for further instructions from dealer. Days later the system lock while driving I the high way i95 and flew of an exit ramp high up and for deep of field. Loosing not just my conscious but came to fine out I got injured on my back and no one took the responsibility on something that could have been avoid as the vehicle was brought to

NHTSA complaint 11550088, quoted in part. Filed by an owner and not verified by NHTSA or by us.

UNKNOWN OR OTHER

1 injured

Panoramic sunroof exploded while driving on route 30, York PA around 740am EST, shattered into pieces, made home late, urgent care closed near me will try again around 5am. Irritating eyes and headache most the day and having constant discomfort and worrying.

NHTSA complaint 11700235. Filed by an owner and not verified by NHTSA or by us.

UNKNOWN OR OTHER

fire

My 2020 BMW 530i caught fire while I was driving on March 13th. The car showed no signs of smoke. Another driver alerted me about smoke, I exited the vehicle, and within minutes the car was fully on fire. The vehicle is currently at a tow yard.

NHTSA complaint 11724573. Filed by an owner and not verified by NHTSA or by us.

ELECTRICAL SYSTEM
The contact owns a 2020 BMW 530I. The contact stated that the check engine warning light was illuminated. The contact stated that while driving from a complete stop, and while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal. Additionally, the contact stated that the infotainment system might have been remotely hacked. The vehicle was taken to the dealer, where it was diagnosed with an air bag failure. Additionally, the contact was informed that the vehicle could not be repaired under NHTSA Campaign Number: 25V636000 (ELECTRICAL SYSTEM); because the part to do the recall repair was not yet available. The vehicle was not repaired. The contact stated

NHTSA complaint 11731883, quoted in part. Filed by an owner and not verified by NHTSA or by us.

STEERING

crash · towed

My car was totaled, I lost steering assistance, and it switched off while I was driving. The car was the subject of an open recall. I need this looked at because it might be a crash caused by a fault.

NHTSA complaint 11717953. Filed by an owner and not verified by NHTSA or by us.

AIR BAGS
I had a diagnostic done and it was discovered that the passenger seat airbag is defective and needs to be replaced

NHTSA complaint 11676327. Filed by an owner and not verified by NHTSA or by us.

FUEL/PROPULSION SYSTEM
My gas tank door would not open. Luckily I was not on a long trip. The vehicles key fob locks and unlocks door along with car doors. The dealer used a special tool to open the door and replaced inside parts. My concern is there is no fail safe to open the gas door. The design is flawed as there should be some sort of manual release in the trunk.

NHTSA complaint 11559309. Filed by an owner and not verified by NHTSA or by us.

Compare

Other years of the BMW 530I

Model year Complaints Recalls Deaths
2024 13 6 —
2022 8 4 —
2021 17 8 —
2019 15 1 —
2018 25 2 —
2017 18 1 —

Other 2020 BMW models

X3 109 X5 103 X7 52 330I 51 M340I 51 X4 14 X1 13 S 1000 RR 10

Every BMW on this site — 249 vehicles, 484 recall campaigns and 2 open investigation s.

If this is your car and a dealer keeps failing to fix it, your state's lemon law may require the manufacturer to replace it or buy it back. What each state asks for , read from the statutes.

Where these numbers come from

A complaint is one owner's account and has not been verified by NHTSA or by us. A vehicle with more complaints is not necessarily worse: models that sold in larger numbers collect more of them. How this is counted.

Compiled and maintained by
Independent developer and analyst