2020 BMW X5

The defect

BMW of North America, LLC (BMW) is recalling certain 2020 340I, X6, 2020-2025 840I, 2020-2022 740LI, 2019-2020 X7, and X5 vehicles. After repeated attempts, the starter motor may overheat from an electrical overload.

The risk

An overheated starter motor can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.

The remedy

Dealers will replace the engine starter, free of charge. This recall includes vehicles repaired under recall 24V576 and those owners will need to have their vehicle repaired again. Owner notification letters were mailed February 9, 2026. Owners may contact BMW customer service at 1-800-525-7417. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov November 17, 2025.

BMW of North America, LLC · up to 145,102 vehicles across all model years covered

The defect

BMW of North America, LLC is recalling certain 2019-2020 X5, X7, 2020 3 Series Sedan, X6, 2020-2021 7 Series Sedan, 2020 8 Series Convertible, 8 Series Coupe, and 2020 8 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. In the event the starter motor fails, repeated attempts to start the vehicle can cause the starter motor to overheat from an electrical overload.

The risk

A starter motor that overheats can ignite nearby combustible material in the engine compartment, increasing the risk of a fire.

The remedy

Dealers will update the vehicle software, free of charge. Owner notification letters were mailed September 27, 2024. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 105,588 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2022 4 Series Gran Coupe (430i, 430i xDrive, M440i xDrive); 2019-2022 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M; 2021-2022 X5 xdrive45e; 2020-2022 X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6M and 2019-2023 X7 xDrive40i, X7 xDrive50i, X7 M50i, X7 xDrive60i, X7 M60i, X7M, Alpina XB7 vehicles. The roof function control unit may be programmed incorrectly, allowing the sunroof to close without the key fob present inside the vehicle. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 118, "Power-Operated Window Systems."

The risk

A sunroof that closes without the key fob present inside the vehicle can increase the risk of injury.

The remedy

Dealers will reprogram the roof function control unit, free of charge. Owner notification letters were mailed June 20, 2022. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 61,221 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2019-2021 X3 sDrive30i, X3 xDrive30i, X3 M40i, X3M, X4 xDrive30i, X4 M40i, M550i, X4M, X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5M, X5 M50i, X7 xDrive40i, X7 xDrive50i, X7 M50i, Alpina XB7, 330i, 330i xDrive, M340i, M340i xDrive, and 8 Series Coupe, Convertible and Grand Coupe, 840i, 840i xDrive, M850i xDrive, M8, 2020-2021 530e, 530e xDrive, 330e, 330e xDrive, 745Le, 745Le xDrive, X5 xDrive45e, X3 xDrive30e, X6 sDrive40i, X6 xDrive40i, X6 xDrive50i, X6 M50i, X6M, 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 740i, 740Li, 740Li xDrive, M760i Drive, M760Li xDrive, 750Li xDrive Alpina, Alpina B7 xDrive, and 2021 4 Series Coupe 430i, 430i xDrive, M440i xDrive vehicles. When shifting into Reverse, a small portion of the rearview image may be obscured, or the screen may not illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

The risk

If the driver relies on only the rearview camera image, the missing or reduced rearview image view can increase the risk of a crash or injury.

The remedy

BMW will notify owners, and dealers will inspect the rearview camera software and update it if necessary, free of charge. The recall began April 16, 2021. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 13,858 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020-2021 8 Series Coupe, Grand Coupe and convertible 840i, 840i xDrive, M850i xDrive, M8 and 740 Li, 740 Li xDrive, 750 Li xDrive, M760 Li xDrive, X6 sDrive40i, X6 xDrive40i, X6 xdrive50i, X6 M50i, X6M, and 2019-2021 X5 sDrive40i, X5 xDrive40i, X5 xDrive50i, X5 M50i, X5M, X7 xDrive40i, X7 xDrive50i, X7 M50i, and 2021 M3, M3 Competition, M4 Coupe, M4 Competition Coupe, X5 xDrive45e, 745 Le xDrive. The rotor and shaft within the integrated brake system may not have been welded properly and could separate during a hard braking event, possibly resulting in a loss of the Antilock Brake System (ABS) and braking assistance.

The risk

A loss of ABS and a reduction in braking assistance can increase the risk of a crash.

The remedy

BMW will notify owners, and dealers will replace the integrated brake system, free of charge. Owner notification letters were mailed on May 25, 2021. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 893 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, xDrive40i, X5 M50i, X5M, X7 xDrive40i, X7 M50i, X6 xDrive40i, X6 M50i and X6M vehicles and 2021 X5 xDrive45e vehicles. The weld between the front axle support and the right front control arm bearing bracket may separate.

The risk

If the weld between the front axle support and the right front control arm bearing bracket separates, vehicle handling and control may be affected, increasing the risk of a crash.

The remedy

BMW will notify owners, and dealers will replace the front axle support, free of charge. The recall began December 18, 2020. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 83 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020-2021 X5 sDrive40i, xDrive40i, xDrive50i, X5 M50i, X5M, X6 sDrive40i, xDrive40i, X6 M50i, X6M, X7 M50i and 2021 X5 xDrive45e vehicles. The headlamps may allow a blue light to illuminate. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

The risk

Oncoming drivers may be confused by the blue light of approaching vehicles, which could potentially increase the risk of a crash.

The remedy

BMW will notify owners, and dealers will inspect the headlamps and, if necessary, replace them, free of charge. The recall began October 30, 2020. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 307 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive 40i, X5 xDrive 40i and one X7 xDrive 40i vehicle. The starter motor may have an extra bolt that could potentially fall into the transmission housing and cause an engine stall.

The risk

An engine stall increases the risk of a crash.

The remedy

BMW will notify owners, and dealers will inspect the starter motor for the extra bolt, removing it if necessary. Dealers will also inspect the starter for damage, and check if the bolt has fallen into the transmission housing, replacing any damaged parts as necessary. All repairs will be performed free of charge. The recall began on October 2, 2020. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 21 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2019-2020 X5 sDrive40i, X5 xDrive40i and X5 xDrive50i vehicles and 2020 X6M vehicles. The steering column shaft bearing plate may not have been properly attached to the vehicle, allowing it to loosen.

The risk

A loose bearing plate can affect the vehicle's handling and control, increasing the risk of a crash.

The remedy

BMW will notify owners, and dealers will inspect the steering column shaft bearing plate and properly attach or replace it, as necessary, free of charge. BMW telephoned owners and all of the vehicles have been remedied. No owner notification letter is necessary. Please contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 7 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2018 540d, 2018-2020 530i, 530i xDrive, 540i, 540i xDrive, M550i xDrive, M5, 530e, 530e xDrive, X3 sDrive, X3 xDrive, X3 M40i, X3 M, and 2019-2020 X4 xDrive, X4 M40i, X4 M, X7 xDrive, X7 M50i, 740Li, 740Li xDrive, 750Li, 750Li xDrive, 8 Series Convertible and Coupe 840i, 840i xDrive, M850i xDrive, X5 sDrive, X5 xDrive, X5 M50i, X6 xDrive, X6 M50i, 330i, 330i xDrive, M340i, M340i xDrive, Z4 sDrive, Z4 M40i, 740Le xDrive and 745Le xDrive, 2018-2019 640i xDrive Gran Turismo and Rolls-Royce Phantom, 2019 M850i xDrive Gran Coupe and Rolls-Royce Cullinan and 2020 Toyota Supra vehicles. The back-up camera and display settings can be adjusted such that the rear view image is no longer visible and the system will retain that setting the next time the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rearview Mirrors."

The risk

The lack of an image in the back-up camera display increases the risk of a crash.

The remedy

BMW will notify owners, and dealers will update the back-up camera software, free of charge. The recall began November 8, 2019. Owners may contact BMW customer service at 1-800-525-7417 or Rolls-Royce at 1-877-877-3735. Toyota owners may contact Toyota customer service at 1-888-270-9371.

BMW of North America, LLC · up to 257,473 vehicles across all model years covered

The defect

BMW of North America, LLC (BMW) is recalling certain 2020 X5 sDrive40i, X5 xDrive40i, X5 M50i, X7 xDrive40i and X7 M50i vehicles. The steering rack pinion teeth may break under load, resulting in a loss of steering control.

The risk

A loss of steering control increases risk of a crash.

The remedy

BMW will notify owners, and dealers will replace the steering rack, free of charge. The recall began August 21, 2019. Owners may contact BMW customer service at 1-800-525-7417.

BMW of North America, LLC · up to 12 vehicles across all model years covered

Closed defect petition · opened January 27, 2023 · closed August 7, 2023 · led to recall 22V063000

the electrical system

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

This vehicle has AC problem it’s blowing hot air. It has evaporator leaking. I called multiple shops and they said this problem is very popular for the X5 2019 to 2023 in my car is 2020. Please recall the Evaporator Core problem. It is too dangerous to drive in the car without AC and is too expensive to Have the Evaporator Core replacement.

NHTSA complaint 11754754. Filed by an owner and not verified by NHTSA or by us.

My 2019 BMW X5 (G05) equipped with the B58 Technical Update (B58TU) engine has experienced a failure / is showing early signs of failure of the engine oil pump assembly.Beginning with the B58TU engine, BMW utilized a variable-displacement oil pump that contains a thermoplastic/plastic internal adjusting ring. This plastic component degrades under normal operating temperatures, resulting in a sudden mechanical failure of the pump. This failure leads to a sudden drop in engine oil pressure, vehicle disablement without sufficient warning, or an inability for the iDrive infotainment system to complete an electronic oil level measurement.A sudden loss of engine lubrication while driving presents …

NHTSA complaint 11754552, quoted in part. Filed by an owner and not verified by NHTSA or by us.

It’s a common issue between 2019-2020 where the oil pump which came from factory has plastic impellers which crack/disintegrate causing catastrophic failure to the engine disabling the vehicle the only warning signs before this happens is you cant read oil level and or the car prompts with a warning low oil messages if untreated the car will have catastrophic engine failure with little to no warning the car was mass produced and this is a common issue therefore should be recalled

NHTSA complaint 11751677. Filed by an owner and not verified by NHTSA or by us.

Low oil pressure light came on during interstate drive. Later analysis at dealership revealed this is related to faulty oil pump with plastic parts in B58 engine.

NHTSA complaint 11750271. Filed by an owner and not verified by NHTSA or by us.

I replaced my starter prior to a recall that was issued. After the recall, I submitted a claim for reimbursement and the check was issued. Bmw of North American has not updated the recall information associated with my vin. I am this unable to list my vehicle on any rental platform as it is showing a status of an open recall for the starter. The repair was done in September, 2025 and I was reimbursed 3 weeks ago.

NHTSA complaint 11749940. Filed by an owner and not verified by NHTSA or by us.

Hello, my front differential recently failed on my BMW. based on some research, this appears to be a manufacturing defect that BMW isn't covering affecting many owners of this car.

NHTSA complaint 11749436. Filed by an owner and not verified by NHTSA or by us.