2021 Honda Insight

The defect

Honda (American Honda Motor Co.) is recalling certain 2018-2021, 2023 Acura TLX, 2019-2024 RDX, 2017-2020, 2022-2026 MDX, 2017-2021, 2023, 2025 Honda Ridgeline, 2017-2022 Pilot, 2019-2021 Passport, 2018-2026 Odyssey, 2019-2022 Insight, 2019-2021 HR-V, 2018-2020 Fit, 2020-2022 CR-V Hybrid, 2017-2022 CR-V, 2017-2018, 2021 Civic Type R, 2017-2021 Civic hatchback, 2016-2020 Civic coupe, 2016-2022 Civic, 2017-2022 Accord Hybrid, and 2016-2022 Accord vehicles. The front passenger seat weight sensor may crack and short circuit, which can cause the air bags to deploy unintentionally during a crash.

The risk

Air bags that deploy unintentionally during a crash increase the risk of injury.

The remedy

Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed July 7, 2026. Owners may contact Honda's customer service at 1-888-234-2138. Honda's numbers for this recall are BOL, WO9, OOA, WOM, XOH, NOC, POD, BOE, UOF, POB, EOG, AOI, QO8, TOJ, DO7, and SOK. This recall expands previous NHTSA recall number 24V064. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning May 29, 2026.

Honda (American Honda Motor Co.) · up to 98,892 vehicles across all model years covered

The defect

Honda (American Honda Motor Co.) is recalling certain 2020-2022 Pilot, Accord, Civic sedan, HR-V, Odyssey, 2020 Civic coupe, Fit, 2021-2022 Civic hatchback, 2021 Civic Type R, Insight, 2020-2021 CR-V, CR-V Hybrid, Passport, Ridgeline, Accord Hybrid, 2020 Acura MDX, 2022 Acura MDX, 2020-2022 Acura RDX, and 2020-2021 Acura TLX vehicles. The front passenger seat weight sensor may crack and short circuit, failing to suppress the air bag as intended.

The risk

An air bag that deploys unintentionally during a crash can increase the risk of injury.

The remedy

Dealers will replace the seat weight sensors, free of charge. Owner notification letters were mailed March 28, 2024. This is a phased recall. Owners may contact Honda customer service at 1-888-234-2138. Honda's numbers for these recalls are XHP and VHQ.

Honda (American Honda Motor Co.) · up to 750,114 vehicles across all model years covered

The defect

Honda (American Honda Motor Co.) is recalling certain 2020 CR-V Hybrid, Accord Hybrid, and 2020-2021 Insight vehicles. The DC-DC converter may shut down and prevent the 12-volt battery from recharging, possibly resulting in a loss of drive power.

The risk

A loss of drive power can increase the risk of a crash.

The remedy

Honda will notify owners, and dealers will update the power converter unit (PCU) software, free of charge. The recall began February 12, 2021. Owners can contact Honda customer service at 1-888-234-2138. Honda's number for this recall is K9E.

Honda (American Honda Motor Co.) · up to 27,838 vehicles across all model years covered

Still open engineering analysis · opened January 17, 2025

forward collision avoidance

On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Engineering Analysis is being opened to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the investigation is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Closed preliminary evaluation · opened March 7, 2024 · closed January 17, 2025

forward collision avoidance

On March 7, 2024, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24008) to assess reports of inadvertent activation of the Automatic Emergency Braking (AEB) system in model year 2019-2022 Honda Insight and 2019-2022 Honda Passport vehicles. The complainants allege activation of the AEB system with no apparent obstruction in the vehicle's path, resulting in rapid vehicle deceleration. Honda indicated that it is aware of a total of 412 reports that may relate to the alleged defect. Honda provided analysis of the alleged defect and stated that some customers possibly had an inadequate understanding of the AEB system and its limitations. However, many consumer complaints received by ODI allege that Honda dealerships were unable to reproduce the condition or state that Honda dealerships informed the consumer that this is considered normal AEB operation. To date, ODI has received a total of 106 consumer complaints of inadvertent activation of AEB in the subject vehicles.In total, ODI reviewed 475 reports involving vehicles with unique VINs that may relate to the alleged defect. Of the reports reviewed by ODI, three (3) allege a crash caused by the inadvertent activation of AEB and two (2) allege injury. This Preliminary Evaluation is being upgraded to an Engineering Analysis (EA25002) to further assess the scope, frequency, and potential safety related consequences of the inadvertent AEB activations. Further, the scope of the Engineering Analysis is being expanded to include assessment of model year 2023 Honda Passport vehicles. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

Closed defect petition · opened January 27, 2023 · closed August 7, 2023 · led to recall 22V063000

the electrical system

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

crash · towed · 6,500 miles

The contact owns a 2021 Honda Insight. The contact stated while driving at 55 mph, a deer jumped in front of the vehicle causing the contact to hit the deer but none of the air bags deployed. The contact mentioned that the automatic brakes were engaged during the incident. No one was injured and a police report was filed. The contact stated no warning lights were illuminated. The vehicle was towed to a dealer and was awaiting an inspection. The manufacturer was not informed of the failure. The failure mileage was approximately 6,500.

NHTSA complaint 11424785. Filed by an owner and not verified by NHTSA or by us.

There is a massive hood flutter when large vehicle drive towards me going above 50mph. It feels and looks like the hood is not latched correctly and going to open into my windshield. This has happened since I purchase the vehicle new in 2021

NHTSA complaint 11730558. Filed by an owner and not verified by NHTSA or by us.

Went in for a typical servicing. They noted that the downstream O2 sensor was damaged by rodents. The vehicle, with around 14k has always been stored in a weather tight garage, never stored outside. There has been no rodents in the building since I owned it from 1999. This is a presumptuous statement I refuted, but they wouldn’t take off, and I felt this is a warranty or recall item. There are lots of speed bumps in the North Portland neighborhood, which may have caused the problem by cable scraping. I believe they documented it as rodents to escape their extended warranty contract requirements. I purchased an O2 sensor, which my independent said I don’t need to use it after taping the …

NHTSA complaint 11712835, quoted in part. Filed by an owner and not verified by NHTSA or by us.

I received a 2021 Insight Seat Weight Sensor Safety Recall in September 2025 saying that recall replacement parts were now available at Honda Dealers. Ever since I received this notice, none of the Atlanta area Honda dealers are able to remedy the defect in my vehicle due to lack of parts, contrary to the notice saying parts are available.

NHTSA complaint 11707122. Filed by an owner and not verified by NHTSA or by us.

Under certain circumstances, the portion of the PCU that controls charging of the 12 volt accessory battery malfunctions, sending the PCU into a "fail safe" mode, preventing battery charging and activating warning displays for the driver. This has caused my vehicle to stall while driving, potentially increasing the risk of a crash. Other honda hybrids during this year have been recalled but not by my VIN number, however I am having the exact same issue. Below has me give a specific date but this happens almost every morning.

NHTSA complaint 11701339. Filed by an owner and not verified by NHTSA or by us.

The brake servo control unit feel simulator which reduces the simulation force provided to the brake pedal during emergency or failed conditions and is a key component of realizing a Regenerative Braking System. It provides a good pedal feeling to a driver, improves energy recovery and ensures braking security. My safety has been put at risk as that part is integral to my brake system (including the hybrid function) e.g. my car was in reverse and the brakes were not responding and had to leave my car. I towed my car to a local independent service provider and they confirmed via the OBD-II scanner that confirmed my break servo control feel simulator is bad and would need to be replaced. …

NHTSA complaint 11699002, quoted in part. Filed by an owner and not verified by NHTSA or by us.