2016 Chevrolet Tahoe

The defect

General Motors, LLC (GM) is recalling certain 2014-2016 Chevrolet Silverado 1500, 2015-2016 Chevrolet Tahoe, and 2014-2015 GMC Sierra 1500 vehicles that may have received an incorrect replacement tensioner cable assembly as part of a previous recall remedy or a subsequent repair. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.

The risk

A broken pretensioner cable reduces the effectiveness of the driver's seat belt, increasing the risk of injury.

The remedy

GM will notify owners, and dealers will replace the driver seat belt lap pretensioner, free of charge. The recall began on May 5, 2021. Owners may contact Chevrolet customer service at 1-800-222-1020, and GMC customer service at 1-800-462-8782. GM's number for this recall is N212330040.

General Motors, LLC · up to 2,568 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain 2015-2020 Chevrolet Suburban, Tahoe, and GMC Yukon, and 2014-2018 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles equipped with a 5.3-liter engine, a 3.08-ratio rear axle and four-wheel drive. If a wheel-speed sensor fails, while the vehicle is traveling between 41 and 60 mph in four-wheel or automatic mode, the Electronic-Brake Control Module (EBCM) software may activate the driveline-protection system.

The risk

Unintended activation of the driveline-protection system will cause unintended braking on the wheel on the opposite side of the failed sensor, causing the vehicle to pull to one side unexpectedly, increasing the risk of a crash.

The remedy

GM will notify owners, and dealers will reprogram the EBCM, free of charge. The recall began December 11, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192261050.

General Motors LLC · up to 652,967 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain 2015-2017 Cadillac Escalade, 2014-2018 Chevrolet Silverado, GMC Sierra, 2015-2018 Chevrolet Suburban, Tahoe, GMC Yukon vehicles. The amount of vacuum created by the vacuum pump may decrease over time.

The risk

As the vacuum level drops, the brake assist decreases, increasing braking effort, extending the distance required to stop the vehicle, thereby increasing the risk of a crash.

The remedy

GM will notify owners, and dealers will reprogram the Electronic Brake Control Module, free of charge. The recall began October 8, 2019. Owners may contact Chevrolet customer service at 1-800-630-2438, Cadillac customer service at 1-800-458-8006 or GMC customer service at 1-800-462-8782. GM's number for this recall is N192268490.

General Motors LLC · up to 3,456,719 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 1500 and Tahoe Police Pursuit and Special-Service vehicles. The flexible steel cable connecting the driver's seat belt to the outboard side of the seat may be repeatedly bent over the seat side shield as the driver enters and exits the vehicle causing the cable to fatigue and separate.

The risk

If the pretensioner cable becomes fatigued or breaks, the driver may not be properly restrained in the event of a crash, increasing their risk of injury.

The remedy

GM will notify owners, and dealers will replace the pretensioner cable and seat side-shield, free of charge. The recall began June 19, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is 18156.

General Motors LLC · up to 23,004 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

The risk

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

The remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.

General Motors LLC · up to 40,683 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

The risk

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

The remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.

General Motors LLC · up to 3,640,162 vehicles across all model years covered

Closed preliminary evaluation · opened November 20, 2018 · closed April 10, 2022 · led to recall 19V645000

the brakes, the hydraulic brakes

On November 20, 2018, the Office of Defects Investigations (ODI) opened PE18-012 to investigate instances of sudden onset of a hard brake pedal that could result in extended stopping distance due to an issue with the brake assist vacuum pump in model year (MY) 2014 through 2016 GMC Sierra 1500 and Chevrolet Silverado 1500 series pickup trucks and MY 2015 through 2016 Cadillac Escalade, Chevrolet Suburban, Chevrolet Tahoe, and GMC Yukon SUVs.If the brake assist vacuum pump fails to operate as intended, the amount of brake power assist supplied to the driver can be significantly reduced, extending the subject vehicle stopping distance. GM stated that the root cause of pump failures was due to foreign debris such as oil sludge in the engine oil. GM stated that this debris can become trapped by the oil inlet filter screen. Under normal operation, this screen allows a small amount of oil into the brake vacuum pump. The foreign debris can, over time, clog the pump which can cause a loss of lubrication and a reduction in the amount of vacuum produced leading to a hard pedal and extended stopping distance.On December 13, 2018, GM issued a Special Coverage (N182202780) for the brake vacuum pump issue in MY 2014-2017 trucks and 2015-2017 SUVs on the K2XX platform for 6 years or 72,000 miles. Special Coverage repair includes the replacement of the vacuum pump and vacuum pump belt. Consumers received notification of the coverage via mail. On September 6, 2019, GM notified NHTSA that it was conducting safety recall 19V-645 which reprograms the electronic brake control module (EBCM) and included approximately 3.5 million trucks and SUVs. In October 2019, GM extended the terms of special coverage N182202780 to 10 years or 150,000 miles as well as now including the entire scope of recall 19V-645. In October 2020, GM expanded the scope of coverage N182202780 to include the MY 2018 Escalade and 2019 Tahoe.The remedy implemented in GM recall 19V-645 appears to be sufficient in addressing the safety-related concerns of this issue. Loss of vacuum assist now occurs at a progressive rate as well as there being a more timely warning of a brake problem to the driver through the driver information center (DIC). In view of the recall action and revision to the special coverage, this Preliminary Evaluation is closed. The agency reserves the right to take additional action if warranted by new circumstances. The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.

On 7/28 while driving my vehicle, the ABS and traction control light came on unexpectedly (the symbol with the car and squiggly line in front of it). Nothing is wrong with the vehicle for these lights to come on as I keep up with all maintenance and repairs to this suv seeing that im the only owner. Then the next day, I noticed my truck keeps accelerating uncontrollably and then out of nowhere, the brakes would activate as if i am driving on ice (its summer time, there is no snow or ice on the roads). This issue keeps happening and today I almost got in a car accident for my vehicle accelerating on its own and when I went to apply the brakes, it barely stop the car. My car has brand new …

NHTSA complaint 11753832, quoted in part. Filed by an owner and not verified by NHTSA or by us.

I have been having issues with the brakes on my 2016 Chevy Tahoe for as long as I can remember. When going very slow, such as in a parking lot or pulling into a parking space, my car feels like I am driving on ice when I brake. I am not sure if I am actually going to stop or hit a car/person. The brake pedal also gets very hard. It makes a squeaking sound and also sounds "airy". It is an intermittent problem and does not happen every single time I press on the brakes when going slow. I received a recall notice back in 2019 for increased brake pedal effort and the dealer reprogrammed something. This however, ultimately did not fix the issue and I have never received any follow up information …

NHTSA complaint 11752862, quoted in part. Filed by an owner and not verified by NHTSA or by us.

56,000 miles

The contact owns a 2016 Chevrolet Tahoe. The contact stated that while driving approximately 10 MPH in sand, the vehicle stalled, and the steering wheel seized. The contact turned off the vehicle, jiggled the steering wheel, and waited approximately 10 minutes before restarting the vehicle to continue driving. The vehicle was taken to a certified mechanic who was unable to duplicate the failure. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 56,000.

NHTSA complaint 11750510. Filed by an owner and not verified by NHTSA or by us.

THERE IS DELAMINATION HAPPENING ON THE HOOD AND ROOF OF MY CAR AND IS PUTTING THE INTEGRITY OF THE CAR AT RISK WITH BARE METAL BEING EXPOSED TO THE ELEMENTS THUS CAUSING RUST AND BREAK DOWN OF THE STRUCTURE OF THE VEHICLE.

NHTSA complaint 11747435. Filed by an owner and not verified by NHTSA or by us.

I live in Lake Charles Louisiana. I have a 2016 Tahoe LTZ my transmission went out .

NHTSA complaint 11727362. Filed by an owner and not verified by NHTSA or by us.

I purchased a 2016 Chevrolet Tahoe on March 8, 2026, in [XXX] . After the sale, I discovered that the vehicle has serious undisclosed safety defects, including evidence that the airbag (Supplemental Restraint System) had previously deployed and was not properly repaired or restored to working condition, and were actually cut and removed from the vehicle and glued and covered up. This defect was not disclosed prior to purchase and represents a significant safety hazard. It is available for inspection. This put my safety and others at risk because if I had not noticed that the airbag system was not working and was removed and if I had been in a wreck who knows the injuries that me or somebody …

NHTSA complaint 11726588, quoted in part. Filed by an owner and not verified by NHTSA or by us.