2016 Volkswagen Beetle

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2016 Beetle and Beetle Convertibles vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.

The risk

An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

The remedy

Dealers will replace the driver's side air bag, free of charge. Owners notification letters were mailed October 26, 2023. Owners may contact Volkswagen's customer service at 1-800-893-5298. Volkswagen's number for this recall is 69EM.

Volkswagen Group of America, Inc. · up to 37,558 vehicles across all model years covered

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2015-2019 GTI, 2015-2016 and 2018-2019 Golf, 2012-2019 Beetle and Beetle Convertible, 2017-2019 Golf SportWagen and 2011-2018 Jetta vehicles equipped with an automatic transmission, manual handbrake and keyless entry. A build-up of silicate on the shift lever micro switch contacts may enable the key to be removed from the ignition when the transmission shift lever is not in "Park."

The risk

Removing the key while the shift lever is in a position other than "Park" increases the risk of an unintended vehicle rollaway that may result in personal injury or a crash.

The remedy

Volkswagen will notify owners, and dealers will install an additional switch and circuit board, free of charge. The recall began November 19, 2019. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 37M2.

Volkswagen Group of America, Inc. · up to 679,027 vehicles across all model years covered

The defect

Volkswagen Group of America, Inc. (Volkswagen) is recalling certain model year 2015-2016 Jetta, Beetle, Beetle Convertible, Passat, Golf and Golf SportWagen vehicles. In the affected vehicles, the camshaft lobe that drives the brake vacuum pump may shear off, resulting in a loss of brake assist.

The risk

If the camshaft lobe shears off there would be a loss of brake assist, lengthening the distance needed to stop the vehicle and increasing the risk of a crash.

The remedy

Volkswagen dealer will update the engine control module (ECM) software. The recall began March 2016. Owners may contact Volkswagen customer service at 1-800-822-8987. Volkswagen's number for this recall is 23R1.

Volkswagen Group of America, Inc. · up to 91,867 vehicles across all model years covered

crash · towed · 20,000 miles

THE RIGHT FRONT TIRE EXPLODED WHILE DRIVING STRAIGHT AHEAD AT 40 MPH. HANKOOK TIRES. NOTHING WAS STRUCK AND THE TIRES HAD NO PREVIOUS DAMAGE. SMOOTH CITY STREET.

NHTSA complaint 11231379. Filed by an owner and not verified by NHTSA or by us.

crash · towed

1.Air bags did not deploy in a three vehicle collision. 2.Passenger and myself could have hit our head on the dashboard or steering wheel. 3. unknown 4.yes, its been inspected by insurance company (the driver at fault). 5. no, no lights have ever come on. Car was always in great condition.

NHTSA complaint 11488404. Filed by an owner and not verified by NHTSA or by us.

30,000 miles

The contact owns a 2016 Volkswagen Beetle. The contact stated that the vehicle was repaired under NHTSA Campaign Number: 22V945000 (Air Bags); however, the repair failed to prevent a failure. The contact stated that the vehicle experienced an air bag failure shortly after the recall repair. The vehicle was taken back to the same local dealer, where it was diagnosed with a driver’s side air bag failure. The vehicle was not repaired. The failure mileage was approximately 30,000.

NHTSA complaint 11761840. Filed by an owner and not verified by NHTSA or by us.

ABS module is defective. This results in numerous warning lights, including abs, traction control, airbags, tire pressure warning, check engine light, epc light, and speed control usability. I have no working abs, seat belt, or traction control, which is a safety issue. There was a previous safety recall for VW with defective abs control modules, 45F2. The problem has been confirmed through an authorized VW repair shop. The part will be made available.

NHTSA complaint 11746396. Filed by an owner and not verified by NHTSA or by us.

On October 21st I had a recall performed at Evansville D- Patrick for a 37M2 shift lever micro switch. Today Nov 5th I was leaving work, pulling out of the drive onto highway and once I got on the road the car lost motion and just rolled. Barely made it across the highway. I got across the street into another lot. Turned car off and back on. You can hear the throttle but tires would not move. It would not go into any gear. It wouldn’t even go into park. It would roll no matter what the gear shifter was in. The work they did was in the gear shifter. So whatever work they performed was not done right. The sensor was bad they installed possibly or they didn’t connect the linkage or cables of …

NHTSA complaint 11697790, quoted in part. Filed by an owner and not verified by NHTSA or by us.

I purchased a 2016 VW Beetle, used, in March of 2025. Over the past few weeks, I have received multiple urgent messages from Volkswagon that I need to have the airbag fixed. The communications say there is a high risk of death or serious injury and urge me to my have the repair done ASAP. They have sent multiple mailings to me and made several phone calls to my home. I am doing everything in my power to get this fixed. I have called all the local dealerships within a 50 mile radius, but they do not have the appropriate parts in stock, and have no idea when parts will be available. I am told that the car is safe to drive (which is the exact opposite of what the mailings say) and they tell me …

NHTSA complaint 11685158, quoted in part. Filed by an owner and not verified by NHTSA or by us.

See attached document for complaint

NHTSA complaint 11574691. Filed by an owner and not verified by NHTSA or by us.

The contact owns a 2016 Volkswagen Beetle. The contact received notification of NHTSA Campaign Number: 22V945000 (Air Bags) however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA complaint 11551351. Filed by an owner and not verified by NHTSA or by us.