2023 Mercedes-Benz E 450

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2023 CLS450, E450, E450 All-Terrain, AMG E53, AMG GT43, AMG GT53, and 2021 AMG CLS53 vehicles. The 48-volt ground cable connection located in the engine compartment may not be tightened properly and may result in the ground cable overheating.

The risk

An overheated ground cable increases the risk of a fire.

The remedy

Dealers will inspect the 48-volt ground cable connection and repair it as necessary, free of charge. Owner notification letters were mailed March 22, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2024MMNNNN.

Mercedes-Benz USA, LLC · up to 12,191 vehicles across all model years covered

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2024 GLE, GLS, C-Class, E-Class, S-Class, SL, GLC, CLS, AMG GT, and G-Class vehicles. Please refer to MBUSA's recall report for specific vehicle details. The fuel pump may shutdown, causing a loss of drive power.

The risk

A loss of drive power can increase the risk of a crash.

The remedy

Dealers will replace the fuel pump, free of charge. Owner notification letters were mailed on June 28, 2024. Owner notification letters will be mailed in phases, on February 23, 2024, April 19, 2024, June 28, 2024, August 9, 2024, October 1, 2024, and December 2, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of NHTSA recall number 23V-445.

Mercedes-Benz USA, LLC · up to 79,676 vehicles across all model years covered

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2023 E450, E350, AMG E63 S, AMG E53, CLS450, AMG GT53, and AMG GT43 vehicles. Due to a software error, the exit warning system audio and visual warnings may fail to alert occupants about approaching vehicles.

The risk

Failure to alert occupants of an approaching vehicle can increase the risk of a crash or injury.

The remedy

Dealers will update the exit warning system software, free of charge. Owner notification letters were mailed September 8, 2023. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2023080005.

Mercedes-Benz USA, LLC · up to 880 vehicles across all model years covered

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2021-2023 C-Class, E-Class, S-Class, CLS, SL, GT, GLC, GLE, GLS, and G-Class vehicles. Please refer to MBUSA's recall report for specific vehicle details. The fuel pump may shutdown, which can result in a loss of drive power.

The risk

A loss of drive power can increase the risk of a crash.

The remedy

Dealers will replace the fuel pump, free of charge. Owner notification letters were mailed on June 14, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2023070012.

Mercedes-Benz USA, LLC · up to 143,551 vehicles across all model years covered

25,000 miles

The contact owns a 2023 Mercedes-Benz E-Class. The contact stated while driving at an undisclosed speed, the engine seized. The contact stated that the failure occurred while making a left turn. In addition, a malfunction error message illuminated. The contact stated while attempting to start the vehicle, the vehicle failed to start with the push to start. However, the vehicle did start using the key fob. The vehicle was taken to the dealer, however the failure was not duplicated. The manufacturer was not made aware of the failure. The failure mileage was approximately 25,000.

NHTSA complaint 11741489. Filed by an owner and not verified by NHTSA or by us.

15,500 miles

The contact owns a 2023 Mercedes-Benz E450. The contact stated that while driving at various speeds with the cruise control activated, a yellow "Active Lane Keeping Assistance is Inoperable" message was displayed, followed by a red "Emergency Braking to Begin" message displayed on the instrument panel. To prevent the failure, the contact immediately deactivated the cruise control. The dealer was notified about the failure on several occasions, and two separate cases were filed with the manufacturer. The dealer replaced the steering wheel, replaced several fuses, and performed several software updates to correct the failure under warranty; however, the failure persisted after each repair. …

NHTSA complaint 11732925, quoted in part. Filed by an owner and not verified by NHTSA or by us.

RE: Continental Pro Contact GX SSR MOE 245/40 R19 98 H M+S Original factory installed Mercedes E450 tires. I had 3 blowouts from hitting small potholes on 3 different tires in 1.5 years. These are complete immediate blowout going completely flat on impact. It could have very dangerous if I were driving a little faster and fortunately there was no other damage to the car or other persons. In each case, I hit a small pothole, and the tire blew out, flat to the ground. Because these are run flat tires, on the first 2 incidents I was able to drive home and to the dealer for tire repair/replacement. The third one was so bad that I could not drive all the way home and had to get towed. But all 3 …

NHTSA complaint 11696441, quoted in part. Filed by an owner and not verified by NHTSA or by us.

RE: Continental Pro Contact GX SSR MOE 245/40 R19 98 H M+S Original factory installed Mercedes E450 tires. I had 3 blowouts from hitting small potholes on 3 different tires in 1.5 years. These are complete immediate blowout going completely flat on impact. It could have very dangerous if I were driving a little faster and fortunately there was no other damage to the car or other persons. In each case, I hit a small pothole, and the tire blew out, flat to the ground. Because these are run flat tires, on the first 2 incidents I was able to drive home and to the dealer for tire repair/replacement. The third one was so bad that I could not drive all the way home and had to get towed. But all 3 …

NHTSA complaint 11696446, quoted in part. Filed by an owner and not verified by NHTSA or by us.

RE: Continental Pro Contact GX SSR MOE 245/40 R19 98 H M+S Original factory installed Mercedes E450 tires. I had 3 blowouts from hitting small potholes on 3 different tires in 1.5 years. These are complete immediate blowout going completely flat on impact. It could have very dangerous if I were driving a little faster and fortunately there was no other damage to the car or other persons. In each case, I hit a small pothole, and the tire blew out, flat to the ground. Because these are run flat tires, on the first 2 incidents I was able to drive home and to the dealer for tire repair/replacement. The third one was so bad that I could not drive all the way home and had to get towed. But all 3 …

NHTSA complaint 11696449, quoted in part. Filed by an owner and not verified by NHTSA or by us.

50 miles

The contact owns a 2023 Mercedes-Benz E450 Convertible equipped with Continental Tires, Tire Line: ProContact GX SSR, Tire Size: 245/40/R19, DOT Number: 16YOF989F4623. The contact stated that while driving at an undisclosed speed over a bumpy road surface, the front driver's side tire experienced a blowout several times, requiring the vehicle to be towed to the dealer, where the front driver's side tire was replaced four times by the dealer. Additionally, the contact stated that the failure recurred while driving, and a tire was replaced. The vehicle manufacturer was notified of the failure, but no assistance was provided. The tire manufacturer was not notified of the failure. The vehicle …

NHTSA complaint 11667542, quoted in part. Filed by an owner and not verified by NHTSA or by us.