2024 GMC Yukon XL

The defect

General Motors LLC (GM) is recalling certain 2021-2024 Cadillac Escalade and Escalade ESV, Chevrolet Silverado 1500, Suburban, and Tahoe, GMC Sierra 1500, Yukon, and Yukon XL vehicles equipped with a 6.2L V8 gas engine. The connecting rod and/or crankshaft engine components may have manufacturing defects that can lead to engine damage and engine failure.

The risk

Engine failure increases the risk of a crash.

The remedy

Dealers will inspect the engine, and as necessary, repair or replace the engine. For vehicles that pass inspection, dealers will add higher viscosity oil, install 6 oil fill cap, replace the oil filter, and update the owner's manual. Repairs will be performed free of charge. Owner notification letters were mailed June 18, 2025. Owners may contact Cadillac customer service at 1-800-333-4223, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is N252494000.

General Motors, LLC · up to 597,571 vehicles across all model years covered

The defect

General Motors, LLC (GM) is recalling certain 2023 Chevrolet Silverado 1500, GMC Sierra 1500, 2023-2024 Chevrolet Tahoe, Suburban, GMC Yukon, Yukon XL, Cadillac Escalade, and Escalade ESV vehicles. The electronic brake control module software may fail to display a warning light when a loss of brake fluid occurs. As such, these vehicles fail to comply with the requirements of Federal Vehicle Safety Standard number 135, "Light Vehicle Brake Systems."

The risk

Without a warning light, the vehicle may be driven with low brake fluid, which can reduce braking performance and increase the risk of a crash.

The remedy

The Electronic Brake Control Module (eBCM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed October 25, 2024. Owners can contact GMC customer service at 1-800-462-8782, Chevrolet customer service at 1-800-222-1020, or Cadillac customer service at 1-800-458-8006. GM's number for this recall is N242447990.

General Motors, LLC · up to 449,671 vehicles across all model years covered · fixed by software update

Still open recall query · opened January 16, 2026

the engine

The Office of Defects Investigation (ODI) has received 36 Vehicle Owner Questionnaires (VOQs) alleging engine failure in vehicles subject to Recall 25V274. In each VOQ, the engine had the recall remedy completed prior to the reported failure incident. Recall 25V-274 addresses vehicles equipped with a L87 6.2L V8 gas engine that experienced engine damage or failure. Recall 25V-274’s remedy includes an engine inspection.  Based on the results of the inspection the vehicle will receive an oil change to a higher viscosity oil or an engine replacement.  The complaints received allege failures of both remedies. ODI is opening this Recall Query (RQ) to assess the adequacy of the remedy for Recall 25V-274. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Still open engineering analysis · opened October 23, 2025

the engine, the engine and its cooling

The Office of Defects Investigation (ODI) has received 1,157 reports of engine bearing failure failures in the L87 6.2L engine produced by General Motors (GM). Of the 1,157 reports received, 173 are outside of the scope of recall 25V-274. These engines are installed in Model Years (MY) 2019–2024 Chevrolet Silverado 1500 and GMC Sierra 1500, and 2021-2024MY Chevrolet Suburban and Tahoe, GMC Yukon/Yukon XL, and Cadillac Escalade/Escalade ESV vehicles. The subject engine failures were investigated as part of a Preliminary Evaluation (PE25001).  GM determined that these engine failures were due to multiple supplier manufacturing and quality issues. GM issued recall 25V-274 to address the supplier manufacturing and quality issues produced between March 1, 2021, and May 31, 2024. Based on the issuance of recall 25V-274, NHTSA has closed PE25001. ODI continues to receive a significant number of reports of engine failure in vehicles outside the scope of 25V-274.  This presents a potential safety risk that warrants further investigation.  ODI is opening this Engineering Analysis (EA) to further evaluate the scope and severity of the potential problem and to fully assess the potential safety-related issues of vehicles built outside the recall scope. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.

Closed preliminary evaluation · opened January 16, 2025 · closed October 23, 2025 · led to recall 25V274

the engine, the engine and its cooling

On January 16, 2025, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE25001 after receiving complaints and field reports concerning engine failures in MY2019-2024 GM’s full-size truck and SUV T1XX platform equipped with the L87 6.2L V8 engine. These complainants alleged engine bearing failures resulting in knocking and growling noises from the engine’s bottom end and in some cases more severe consequences such as broken connecting rods leading to engine damage, or engine failure. If the engine fails during vehicle operation, the vehicle will lose propulsion, increasing the risk of a crash. On April 24, 2025, GM issued recall 25V-274 to address the concern with L87 engines produced between March 1, 2021, and May 31, 2024.  GM cited the root cause as a supplier manufacturing and quality issues. GM’s  recall remedy will be either an oil change to an oil with a different viscosity or engine replacement depending on the results of the remedy inspection procedure. To date, ODI has received 1,157 allegations of engine bearing failure. GM submitted 55,464 reports in total, with 29,752 unique VINs. ODI continues to receive allegations of L87 engine failures which fall outside of the scope of recall 25V-274. Based on GM’s recall, ODI will close this PE. NHTSA will continue to investigate complaints of engine failure outside the scope of recall 25V-274 as part ofEngineering Analysis (EA25007). To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

towed · 24,000 miles

The contact owns a 2024 GMC Yukon XL. The contact stated that while driving at 70 MPH, the vehicle lost motive power and decelerated. The contact was able to coast over to the side of the road. The vehicle was towed to the dealer and was diagnosed with crankshaft and rod bearing failure. The vehicle was previously included in NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, it was determined that the engine was not defective and did not need to be replaced. The vehicle was scheduled for engine replacement, but had not yet been repaired. The manufacturer was informed of the failure, and a case was opened. The failure mileage was approximately 24,000.

NHTSA complaint 11695228. Filed by an owner and not verified by NHTSA or by us.

towed · 32,000 miles

The contact owns a 2024 GMC Yukon XL. The contact stated that while driving at 70 MPH on the highway and attempting to accelerate around a possible drunk driver traveling on the roadway, the vehicle failed to respond as needed. The driver was able to pull over safely. There were no warning lights illuminated. The contact called 911 and called for Roadside Assistance, and the vehicle was towed to a local dealer, where it was diagnosed with an engine failure. The vehicle was not repaired. The vehicle was previously taken to the local dealer to be repaired under NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was contacted, but no assistance was provided. The …

NHTSA complaint 11712025, quoted in part. Filed by an owner and not verified by NHTSA or by us.

towed · 14,589 miles

The contact owns a 2024 GMC Yukon XL. While the contact's wife was driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. In addition, the contact's wife noticed an abnormal knocking sound before the engine seized. The check engine warning light illuminated. The vehicle was towed to the dealer, where it was diagnosed and DTC: P0305 (lifter on cylinder 5); was retrieved, and the intake valve detached and damaged the camshaft. The contact was informed that the lifters and related parts, camshaft, and the coolant pump needed to be replaced. The vehicle was repaired; however, the failure reoccurred. The vehicle was taken back …

NHTSA complaint 11719490, quoted in part. Filed by an owner and not verified by NHTSA or by us.

towed · 27,800 miles

The contact owns a 2024 GMC Yukon XL. The contact stated that upon taking the vehicle to the dealer to be repaired under NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling), the contact was informed that the vehicle passed the inspection and no repair was needed. However, the vehicle experienced engine failure approximately seven months later. While driving 50 MPH, the vehicle lost motive power. There was no warning light illuminated. The driver pulled over, restarted the vehicle, and resumed normal driving. The vehicle was taken to the dealer the following morning, where the Electronic Control Module was replaced under warranty; however, the failure recurred while driving 70 MPH …

NHTSA complaint 11756300, quoted in part. Filed by an owner and not verified by NHTSA or by us.

Driving on highway, engine stopped while driving 70+ mph. Had to get to the side of the multilane highway. Was towed to nearest GMC dealership. Dealer said the engine was locked up, and they have many vehicles right now with similar problems. They will have to replace the engine due to complete engine failure.

NHTSA complaint 11754396. Filed by an owner and not verified by NHTSA or by us.

6.2 engine seized again after oil change 3 days after This is my 3 rd Yukon that has done this and I’m not agreeing this shouldn’t be a recall I’ve been through this before

NHTSA complaint 11753416. Filed by an owner and not verified by NHTSA or by us.

We're in the waiting period for our 3rd engine. 1st engine failure, while driving on interstate at 70+ MPH, engine stopped running, causing a very unsafe condition for family and surrounding vehicles. Engine failure 2 days later, towed to dealership for inspection, replacement engine was installed ~4 weeks later. 2nd engine failure, while driving on interstate at 75+ MPH, engine seemed underpowered and would rev upwards of 6000+RPMs, not exactly unsafe, but not usual operating conditions either. Returned to dealer, upon inspection, total engine replacement was recommended.

NHTSA complaint 11750745. Filed by an owner and not verified by NHTSA or by us.

Cameras go black and become inop randomly. Been in shop multiple times for concern. Software updates have been performed, modules replaced, cables, and now it’s back for the same concern.

NHTSA complaint 11749817. Filed by an owner and not verified by NHTSA or by us.

Driving on highway at 80 MPH and accelerator stopped working and car turned off. We had to coast off toll rd and hope for the best. No warning and happened with our whole family in the car. I had a recall notice from manufacturer but last time I tried contacting manufacturer/dealer they said no resolution was available to repair recall yet and that I couldn’t drop off my vehicle.

NHTSA complaint 11748343. Filed by an owner and not verified by NHTSA or by us.