2019 Mercedes-Benz CLA 250

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2014-2020 C-Class, CLA, GLA, S-Class, GLC, and GLE vehicles. Please refer to MBUSA's recall report for specific vehicle details. The front roof panel located between the windshield and the panoramic sunroof may not have been bonded correctly to the vehicle during a prior repair, allowing the front panel to detach from the vehicle.

The risk

A detached roof panel can become a road hazard, increasing the risk of a crash.

The remedy

Dealers will replace the front panel, free of charge. Owner notification letters were mailed on August 2, 2024. Owner notification letters will be mailed in phases, on, March 22,2024, and August 2, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of NHTSA recall number 21V-197.

Mercedes-Benz USA, LLC · up to 2,976 vehicles across all model years covered

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2017-2022 CLA-Class, GLA-Class, GLE-Class, GLS-Class, SLC-Class, A-Class, AMG GT-Class, C-Class, E-Class, S-Class, SL-Class, GLC-Class, CLS-Class, GLB-Class, and G-Class vehicles. Please refer to MBUSA's recall report for specific vehicle model details. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.

The risk

A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.

The remedy

The communication module software will be updated through an Over-the-Air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed July 8, 2022. Owner notification letters will be mailed in phases, on July 8, 2022, May 17, 2024, July 29, 2024, and September 27, 2024. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's numbers are for this recall is 2022060005 and 2023110006.

Mercedes-Benz USA, LLC · up to 242,722 vehicles across all model years covered · fixed by software update

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2017-2020 C300 Coupe, C43 Coupe AMG, C43 AMG, 2015-2020 C300, GLA250, 2016-2018 C350e, CLA45 Coupe AMG, 2015 C400, S65 AMG, 2015-2019 C63 AMG, 2016 C450, 2015-2016 GLA45 AMG, S600, 2016-2020 GLC300, 2017-2019 GLC43 AMG, GLE43 Coupe AMG, 2014-2019 CLA250 Coupe, 2014-2015 CLA45 AMG, 2018 GLC63 AMG, 2014-2017 S550, 2018-2020 S450, 2016-2019 GLE63 Coupe AMG, 2016 GLE450 Coupe, 2014-2020 S63 AMG, 2018-2019 S560, and 2019 GLC350e vehicles equipped with a panoramic sunroof. The front roof panel located between the windshield and the panoramic sunroof may not have been bonded correctly to the vehicle during a prior repair.

The risk

The adhesive bonding of the front panel might deteriorate, possibly causing the front panel to detach from the vehicle and become a road hazard, increasing the risk of a crash.

The remedy

Mercedes-Benz dealer will remove the bonded panel and will install a new front panel by following the detailed repair instructions and using the approved primer, cleaner and adhesive, free of charge. Owner notification letters were mailed on September 3, 2021 and October 26, 2021. Owners may contact MBUSA customer service at 1-800-367-6372.

Mercedes-Benz USA, LLC · up to 15,096 vehicles across all model years covered

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2017-2019 C300, E300, 2018-2020 CLA250, 2020 CLS450, AMG E53, AMG GT53, GLE450, 2018 AMG E63, AMG GTA, 2017-2020 GLA250, GLC300, 2019 GLC350, AMG GLC43, 2017-2018 GLE350, 2019 AMG GLC 43, GLC350, GLE400, 2017 GLS450, S550, C300 Cabrio, and 2018-2019 S560 vehicles. On June 18, 2021, an additional 9 vehicles were added, including certain 2021 GLA250, GLC300, 2018 S450, E400, and 2017 CLA250 vehicles. The communication module might have been inadvertently deactivated during a service visit, which could have disabled the Emergency Call (eCall) function.

The risk

A disabled eCall system would prevent a vehicle occupant from contacting emergency services through the call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.

The remedy

MBUSA will notify owners, and dealers will inspect the communication module and activate it, if necessary, free of charge. The recall began March 31, 2021. Letters for the owners of the 9 additional vehicles were mailed July 9, 2021. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2021030005.

Mercedes-Benz USA, LLC · up to 67 vehicles across all model years covered

The defect

Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2016 - 2021 CLA-Class, GLA-Class, GLE-Class, GLS-Class, SLC-Class, A-Class, GT-Class, C-Class, E-Class, S-Class, CLS-Class, SL-Class, B-Class, GLB-Class, GLC-Class, and G-Class vehicles. Please refer to the Part 573 report for specific vehicle model details. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.

The risk

Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.

The remedy

MBUSA will notify owners, and the communication module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. The recall began March 12, 2021. Owners may contact MBUSA customer service at 1-877-762-8267. MBUSA's number for this recall is 2021020025.

Mercedes-Benz USA, LLC · up to 1,292,258 vehicles across all model years covered · fixed by software update

The defect

Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2019 CLA250 and CLA250 4MATIC vehicles. The right side door locks may not have been properly manufactured. As a result, the right-side doors may not be able to be opened from outside of the vehicle.

The risk

In the event of a crash, if the right side doors cannot be opened from the outside, it could increase the risk of injury.

The remedy

MBUSA will notify owners, and dealers will replace the door locks, free of charge. The recall began May 3, 2019. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2019030020.

Mercedes-Benz USA, LLC. · up to 5 vehicles across all model years covered

Closed preliminary evaluation · opened January 8, 2021 · closed October 14, 2021 · led to recall 21V197000

the body structure

On January 8, 2021, after ongoing review with Mercedes Benz, the National Highway Traffic Safety Administration (NHTSA) Office of Defects Investigation (ODI) opened PE21-001 to assess allegations of front roof panel detachments while driving at highway speeds in certain 2015 Mercedes-Benz (Mercedes) C-Class vehicles.The subject front roof panel is a stationary panel composed of polycarbonate and is attached to the vehicle via adhesive at the time of manufacture. The panel is found on subject vehicles equipped with panoramic sunroofs. Over time, the subject panels may exhibit cosmetic degradation leading to replacement of the panel, a procedure which entails: removal of the old panel and adhesive, site preparation, and installation of a replacement panel with new adhesive.The consumer complaints that prompted the opening of PE21-001 all described detachments of front roof panels that had been replaced after the vehicle was put into service.Mercedes' internal investigation identified a broader scope of affected vehicles (2014-2020 CLA, GLA, C, S, GLC, and GLE class) and found the following potential service procedure- related causes of front roof panel detachments:- Improper surface pretreatments such as the use of the wrong primer or cleaner or scoring of the surface; or - Use of the incorrect adhesive.These conditions lead to a front roof panel bond that, even if sound at the time of repair, cannot maintain its strength over time and environmental exposure.Mercedes updated its service and parts ordering systems to reinforce the proper use of specified kits and procedures via webinars, shop foreman meetings, and explicit reference to the risks incurred by diverging from the repair procedures. Mercedes is also furnishing parts ordering assistance, and will hold dealerships accountable for improper repairs.ODI's analysis of the ten complaints it has received from the public (VOQ's) and MBUSA's complaint data submitted in response to the information request letter for PE21-001 identified a total of 57 non-duplicative reports alleging incidents in which the front roof panel detached from the vehicle while in motion. Included within the 57 reports are incidents where consumers state the panel detached ...and flew off into traffic.On March 19, 2021, Mercedes notified NHTSA that it would recall subject vehicles with front roof panels known to have been replaced after the original sale of the vehicle. In total, the recall (designated as Recall 21V197) covers 15,099 vehicles that were ever registered in the United States. Based on Recall 21V197 and the remedy implemented by Mercedes, further investigation does not appear to be warranted at this time.Accordingly, this investigation is closed.The ODI complaints cited above can be viewed at www.nhtsa.gov under the following ODI identification numbers: 11376425, 11352686, 11351629, 11349158, 11341541, 11337594, 11324100, 11311591, 11222127, 11404183

To Whom It May Concern, I am writing to file a formal safety complaint regarding my 2019 Mercedes-Benz CLA250 involving a leaking fuel rail that caused the vehicle to shut down and become unsafe to operate. The failure of the fuel rail resulted in a fuel leak and engine shutdown. A failure within the fuel delivery system presents a serious safety concern, as it can cause sudden loss of power while driving and poses a potential fire hazard if fuel comes into contact with hot engine components. During the repair process, I was informed that the necessary replacement component, Fuel Rail Part Number 2700701995, is no longer being produced by Mercedes-Benz. Because this critical component is …

NHTSA complaint 11723718, quoted in part. Filed by an owner and not verified by NHTSA or by us.

The sunroof is off the track. There seems to have been a recall for my make and model and year of vehicle (2019 Mercedes CLA 250) though Mercedes tells me that my vin # is not among those that were recalled. However, they told me that if I could reach out to NHTSA, that it would be possible that my vehicle would be added to the recall, which would force Mercedes to have to repair the issue at their cost, so this is me doing that.

NHTSA complaint 11719214. Filed by an owner and not verified by NHTSA or by us.

JUST PAID $4,154.67 TO HAVE MY 2019 MERCEDES CLA 250, WITH JUST 46,222 MILES, ENGINE REPAIRED. * REPACE FUEL INJECTOR SEALS/ORINGS $1,462.80 *REPLACE ALL 4 FUEL INJECTORS $2,512.62 SO, PLEASE TELL WHY THERE IS NO RECALL ON MY CAR????? MARK BOULTINGHOUSE (240)277.9752

NHTSA complaint 11718332. Filed by an owner and not verified by NHTSA or by us.

My 2019 Mercedes-Benz CLA 250 has become unsafe to drive due to strong gasoline fumes filling the cabin. The smell is overwhelming and makes it difficult — and frankly dangerous — to sit in the vehicle for more than a few minutes without feeling lightheaded. I have since learned that this issue is part of a known defect covered under NHTSA Recall #21V961, which affects 2016–2020 CLA 250 models for a fuel leak and potential fire hazard. Despite the recall directly describing this exact problem — fuel vapors entering the passenger compartment — I was told that Mercedes-Benz will not cover the repair costs, even though the recall was never performed on my car. This is deeply concerning, as …

NHTSA complaint 11701109, quoted in part. Filed by an owner and not verified by NHTSA or by us.

My 2019 Mercedes-Benz CLA 250 has become unsafe to drive due to strong gasoline fumes filling the cabin. The smell is overwhelming and makes it difficult — and frankly dangerous — to sit in the vehicle for more than a few minutes without feeling lightheaded. I have since learned that this issue is part of a known defect covered under NHTSA Recall #21V961, which affects 2016–2020 CLA 250 models for a fuel leak and potential fire hazard. Despite the recall directly describing this exact problem — fuel vapors entering the passenger compartment — I was told that Mercedes-Benz will not cover the repair costs, even though the recall was never performed on my car. This is deeply concerning, as …

NHTSA complaint 11698613, quoted in part. Filed by an owner and not verified by NHTSA or by us.

As i was driving on the freeway the front acylic panel conected to the sun roof just fell off the car nearly striking another vehicle. I have bein seeing alot of other ppl are having this issue yet it has not been recalled

NHTSA complaint 11690040. Filed by an owner and not verified by NHTSA or by us.