2016 Chevrolet Silverado 3500

The defect

General Motors, LLC (GM) is recalling certain 2016 Chevrolet Silverado 2500/3500, GMC Sierra 2500/3500 vehicles, and 2016-2017 Chevrolet Silverado 1500 and GMC Sierra 1500 vehicles. The left-side or right-side roof rail air bag (RRAB) inflator end cap may detach from the inflator or the inflator sidewall may rupture.

The risk

A detached end cap or inflator rupture can allow compressed gas to escape and project the end cap or fragments of the inflator into the vehicle, increasing the risk of injury.

The remedy

Dealers will replace both RRAB modules, free of charge. Owner notification letters are expected to be mailed November 9, 2026. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N262569920. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 24, 2026.

General Motors, LLC · up to 1,559 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain 2015-2016 GMC Sierra 1500, 2500, 3500, and Chevrolet Silverado 1500, 2500, and 3500 trucks. The roof-rail air bag (RRAB) inflator end cap may detach from the inflator, or the inflator sidewall may rupture.

The risk

A separated inflator end cap or inflator rupture can allow compressed gas to escape, resulting in the end cap or other components being propelled into the vehicle, increasing the risk of injury or crash.

The remedy

Dealers will replace the left and right side RRAB modules, free of charge. Interim owner notification letters informing owners of the safety risk were mailed on August 18, 2021. Owners will receive a second notice when the remedy is available. Phase I owner notification letters were mailed on May 5, 2022. Phase II owner notification letters are expected to be mailed on May 31, 2022. Owners may contact GMC customer service at 1-888-988-7267 or Chevrolet customer service at 1-800-222-1020. This recall supersedes NHTSA recall number 20V-736. GM's number for this recall is N202324251.

General Motors, LLC · up to 410,019 vehicles across all model years covered

The defect

General Motors, LLC (GM) is recalling certain 2016-2018 GMC Sierra 3500 and Chevrolet Silverado 3500 trucks equipped with gasoline engines and dual fuel tanks. The fuel-level sensor in the front tank may stick in a low-level position, allowing the rear tank to overfill the front tank.

The risk

If the front tank overfills, the excess pressure may cause the front tank to expand and contact the driveshaft, possibly resulting in a hole in the tank. The hole will leak fuel, which in the presence of an ignition source, can increase the risk of a fire.

The remedy

GM has notified owners, and dealers will replace the rear-tank fuel-pump module, inspect the front tank and, if necessary, replace the front tank, free of charge. The recall began July 30, 2019. GM's number for this recall is N182204190.

General Motors LLC · up to 18,574 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain 2015-2016 Chevrolet Silverado 2500, 3500, 1500 Crew Cab Special Service, Tahoe Police Pursuit/Special Service, GMC Sierra 2500, and 3500 vehicles. The brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.

The risk

If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.

The remedy

GM will notify owners, and dealers will add adhesive to the nut and reinstall the nut with increased tightness, free of charge. The recall began October 3, 2018. Owners may contact Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 18278. Note: The vehicles in this recall need this additional remedy despite being covered by recall 16V069 for brake pedal loosening.

General Motors LLC · up to 42,280 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain model year 2014-2016 Buick Lacrosse and Chevrolet Spark EV, Caprice PPV and SS vehicles, 2014-2017 Buick Encore and Chevrolet Corvette, Silverado 1500 and GMC Sierra 1500 vehicles, 2015-2016 Cadillac Escalade and Escalade ESV, Chevrolet Tahoe, Trax, Suburban and Silverado 2500 and 3500 and GMC Yukon and Yukon XL vehicles, and 2015-2017 GMC Sierra HD 2500 and 3500 vehicles. While being previously remedied for recall 16V-651, the affected vehicles may not have received the complete software update necessary to remedy the recall condition. Without the update, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

The risk

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

The remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on August 4, 2017. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 17287.

General Motors LLC · up to 40,683 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain model year 2015-2017 Chevrolet Silverado 2500 HD, 3500 HD, Tahoe, Suburban, GMC Sierra 2500 HD and 3500 HD, GMC Yukon, GMC Yukon XL, Cadillac Escalade and Cadillac Escalade ESV vehicles and 2014-2017 Chevrolet Corvette, Silverado 1500, Trax, Caprice Police Pursuit Vehicle, GMC Sierra 1500, Buick Encore, and 2014-2016 Buick Lacrosse, Chevrolet Spark EV and SS vehicles. In the affected vehicles, certain driving conditions may cause the air bag sensing and diagnostic module (SDM) software to activate a diagnostic test. During this test, deployment of the frontal air bags and the seat belt pretensioners would not occur in the event of a crash.

The risk

A failure of the front air bags or seat belt pretensioners to deploy in the event of a crash necessitating deployment increases the risk of injury to the driver and front passenger.

The remedy

GM will notify owners, and dealers will reflash the SDM software. Vehicles that have had a previous air bag deployment will have the SDM replaced. These repairs will be performed free of charge. The recall began on October 13, 2016. Owners may contact Buick customer service at 1-800-521-7300, Cadillac customer service at 1-800-458-8006, Chevrolet customer service at 1-800-222-1020, or GMC customer service at 1-800-462-8782. GM's number for this recall is 16007.

General Motors LLC · up to 3,640,162 vehicles across all model years covered

The defect

General Motors LLC (GM) is recalling certain model year 2015-2016 Chevrolet Silverado 1500, 2500, and 3500 heavy duty trucks manufactured October 1, 2013, to February 1, 2016, 2015-2016 Chevrolet Tahoe Police Pursuit Vehicles (PPV) manufactured March 1, 2014, to February 1, 2016, and 2015-2016 GMC Sierra 2500 and 3500 heavy duty trucks manufactured October 29, 2013, to February 1, 2016. On the affected vehicles, the brake pedal pivot nut may loosen, causing the brake pedal to be loose or inoperative.

The risk

If the brake pedal becomes loose or inoperative, the driver may be unable to stop the vehicle by using the brake pedal. Additionally, a loose pedal may also interfere with the accelerator pedal. Either condition may increase the risk of a crash.

The remedy

GM will notify owners, and dealers will add adhesive to the brake pedal pivot nut and reinstall with an increased torque, free of charge. The recall began on March 14, 2016. Owners may contact Chevrolet customer service at 1-800-222-1020 or GMC customer service at 1-800-462-8782. GM's number for this recall is 20760.

General Motors LLC · up to 430,771 vehicles across all model years covered

crash · towed

I have now been in 2 serious accidents that resulted in all other vehicles deploying airbags and being totalled, but mine have never deployed and it has been suggested there may be a recall for this

NHTSA complaint 11719502. Filed by an owner and not verified by NHTSA or by us.

towed · 4,000 miles

TL* THE CONTACT OWNS A 2016 CHEVROLET SILVERADO 3500. WHILE DRIVING APPROXIMATELY 70 MPH HAULING A GOOSE NECK FLATBED DUEL TANDEM TRAILER, THE POWER BUS BAR SHORTED. IN ADDITION, THERE WAS A FAILURE WITH A LOOSE WIRE ASSOCIATED WITH THE STARTER. THE RADIO WOULD NOT TURN OFF AND THE CONTACT WAS LOCKED IN THE VEHICLE. THE CONTACT WAS ABLE TO EXIT THE VEHICLE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER TIGHTENED THE WIRES AND REPLACED ALL OF THE BUS BARS. THE NEXT MORNING, WITHIN LESS THAN 20 MILES, THE BUS BARS FAILED AGAIN. THE BRAKE, TRACTION CONTROL, AND OTHER WARNING INDICATORS AND GAUGES ILLUMINATED. THE CONTACT WAS LOCKED IN THE VEHICLE AND HAD TO MOVE THE …

NHTSA complaint 10909332, quoted in part. Filed by an owner and not verified by NHTSA or by us.

Leak is causing black mold, creating an unsafe environment inside the vehicle where child is expected and required by law to be buckled right above a black mold infected carpet and behind headrest

NHTSA complaint 11761963. Filed by an owner and not verified by NHTSA or by us.

As I was driving I heard a loud slam under my hood and when I checked the clutch for my AC compressor was gone. The AC no longer works and I have no idea where the parts went. When I looked this up it appears to be a common issue.

NHTSA complaint 11719506. Filed by an owner and not verified by NHTSA or by us.

Power steering intermittently goes out. Mostly when it's hot out, slow speeds, and cornering.

NHTSA complaint 11669885. Filed by an owner and not verified by NHTSA or by us.

While connected to a RV which has onboard batteries, the truck's brake controller disables the braking system if the batteries on the RV fluctuate in voltage. The truck will give an alert advising "Trailer Brakes Disabled." This has occurred multiple times while pulling my RV which weighs 16,000 pounds, making it unsafe and hard to stop using only the truck's brakes. It happened while traveling through Atlanta, GA and once in Nashville, TN. Chevrolet has at least one TSB on this for similar 2022-2024 2500 and 3500 trucks. This has been a widely reported problem on several RV forums. The truck brake controller will work again if the engine is shut off and turned back on or the trailer is …

NHTSA complaint 11648847, quoted in part. Filed by an owner and not verified by NHTSA or by us.

On [XXX] while traveling down [XXX] in VA I experienced a catastrophic Bosch CP4 Fuel Pump Failure. Vehicle was towed to Marion Auto Group in Marion, VA and kept for 5 weeks to repair fuel system. We paid $6,500 once we were told the repairs were complete and picked the vehicle up. Within 50 miles of driving, the fuel system error lights/codes began again and the service engine light came on. We called Marion Auto Group, they told us it was warranted for 24 months for parts and labor. We could take it to any Chevy dealer and have it looked at. We made an appt with our local Chevy dealer, Joe Bowman Chevrolet in Harrisonburg, VA. They kept the vehicle for approximately 5-6 weeks. Told us …

NHTSA complaint 11634518, quoted in part. Filed by an owner and not verified by NHTSA or by us.